Remove/Install Rear Roof Paneling - AR68.30-S-7608EA
Model 447.7
With Code ZH6 (Marco Polo ACTIVITY)
Shown On vehicle With Code EZ7 (Active parking assist)
Shown On headliner (1) With Code EZ7 (Active parking assist)
| Risk of injury caused by fingers being jammed or pinched when removing, installing or aligning hoods, doors, trunk lid/rear-end door or sliding roof. | No parts of the body or limbs should be within the operating area when the components are moving. | AS00.00-Z-0011-01A | |
| Notice | Notes on carrying out repair work in the vehicle interior | AH68.00-D-0001-01KOS | |
| Remove/install | |||
| 1 | Remove bed extension | AR91.75-S-0010EE | |
| 2 | Fold backrest of passenger bench seat toward rear | ||
| 3 | Remove all rear air vents | Model 447.7 with CODE HZ7 (Semi-automatically controlled air conditioning, TEMPMATIC in rear) | AR83.10-S-4800E |
| 4 | Remove all handles from roof | AR68.30-S-4330E | |
| 5.1 | Remove curtain on left side window in rear from B-pillar | Model 447.7 except CODE T19 (Left sliding door) If the headliner (1) is not replaced. | |
| 5.2 | Remove all curtains for side window in rear | If the headliner (1) is being replaced. | AR68.50-S-7816E |
| 6 | Remove paneling from left and right C-pillar | Model 447.7 with code V23 (Interior trim, superior version) | AR68.30-S-4490E |
| 7 | Remove paneling on left and right D-pillar | AR68.30-S-4495E | |
| 8 | Remove rear trim on roof cutout for pop-up roof (2) | AR77.70-S-0021E | |
| 9 | Detach headliner (1) in area of magnets (4) from roof until electrical connector on cargo area lamp (5) is accessible | Carefully lower headliner (1). Otherwise the headliner (1) can be damaged. |
|
Ensure that headliner (1) is seated correctly in sealing frame of sliding door, liftgate and rear side window. |
|||
| 10 | Disconnect electrical connector from PARKTRONIC system warning indicator (PTS) in rear (3) | Model 447.7 with code EZ7 (Active parking assist) | |
| 11 | Disconnect electrical connector from cargo area lamp (5) and guide headliner (1) out of vehicle interior toward rear | Carefully guide out headline (1). Otherwise the headliner (1) can be damaged. |
|
| 12 | Remove PARKTRONIC system warning indicator (PTS) in rear (3) | Model 447.7 with code EZ7 (Active parking assist) If the headliner (1) is being replaced. |
AR54.65-S-0007E |
| 13 | Remove cargo area lamp (5) | If the headliner (1) is being replaced. | |
| 14 | Remove all support rods from curtains for side window in rear | If the headliner (1) is being replaced. | AR68.50-S-7816E |
| 15 | Prepare roof paneling (1) for installation | If the headliner (1) is being replaced. |
AR68.30-S-4305-15E |
| 16 | Install in the reverse order | ||
| Check | |||
| 17 | Check electrical components in repair area for proper function |