Section 217 (Engine Mechanical - 1.4L (LDD, LDU, LUH, Or LUJ) - Repair Instructions - Off Vehicle (1 Of 2))
WARNING: This page is about a different car, the 2011 Chevrolet Cruze. However, it is still accessible from the selected car via links, so may be relevant.
- Engine Support Fixture
- Engine Mount Bracket Removal
- Camshaft Timing Chain Inspection
- Camshaft Timing Chain Adjustment
- Draining Fluids and Oil Filter Removal
- Positive Crankcase Ventilation Pipe Removal
- Exhaust Manifold Heat Shield Removal (1.4L LUH and LUJ)
- Warm Up Three-Way Catalytic Converter Removal (1.4L LUH and LUJ)
- Turbocharger Removal
- Engine Oil Cooler Removal
- Engine Coolant Thermostat Housing Removal (1.4L LUH and LUJ)
- Water Outlet Removal (1.4L LUH and LUJ)
- Drive Belt Tensioner Removal
- Air Conditioning Compressor Bracket Removal
- Water Pump Pulley Removal
- Crankshaft Balancer Removal
- Water Pump Removal
- Throttle Body Removal (1.4L LUH and LUJ)
- Intake Manifold Removal (1.4L LUH and LUJ)
- Generator Removal
- Starter Removal
- Engine Flywheel Removal (1.4L LUH and LUJ)
- Ignition Coil Removal
- Camshaft Cover Removal
- Camshaft Position Actuator Solenoid Valve Removal
- Engine Oil Heater Removal
- Oil Pan Removal
- Engine Front Cover and Oil Pump Removal
- Camshaft Timing Chain Removal
- Timing Chain Tensioner Removal
- Engine Front Cover Gasket Removal
- Camshaft Sprocket Removal
- Intake Camshaft Removal
- Exhaust Camshaft Removal
- Hydraulic Valve Lash Adjuster Arm Removal
- Hydraulic Valve Lash Adjuster Removal
- Cylinder Head Removal
- Piston, Connecting Rod, and Bearing Removal
- Crankshaft and Bearing Removal
- Cylinder Head Disassemble
- Cylinder Head Cleaning and Inspection
- Cylinder Head Assemble
- Engine Block Disassemble (1.4L LUH and LUJ)
- Engine Block Assemble (1.4L LUH and LUJ)
- Piston and Connecting Rod Disassemble (1.4L LUH and LUJ)
- Piston, Connecting Rod, and Bearing Cleaning and Inspection (1.4L LUH and LUJ)
- Piston and Connecting Rod Assemble (1.4L LUH and LUJ)
- Intake Manifold Disassemble (1.4L LUH and LUJ)
- Intake Manifold Cleaning and Inspection
- Intake Manifold Assemble (1.4L LUH and LUJ)