Section 17 (Rear Axle - Repair - E90/E91)
WARNING: This page is about a different variant/trim than selected.
- 00 General
- 00 Danger of poisoning if oil is ingested/absorbed through the skin
- 00 Risk of injury if oil comes into contact with eyes and skin
- 00 Safety instructions for handling oil
- 00 ... ... Raising vehicle with trolley jack
- 33 .. . Rear axle layout
- 33 00 ... Information on replacing shock absorbers
- 33 00 ... Instructions (chassis components made of aluminium)
- 33 00 ... Notes on repairing threads
- 33 00 ... Rear axle: wheel/chassis alignment check must be carried out after the following work
- 33 31 ... Overview of rear axle carrier with rubber mounts
- 33 32 ... Overview of steering links
- 10 Final drive
- 11 Final drive with cover
- 00 11 ... Checking/topping up oil level in rear differential
- 00 11 259 Oil change in rear differential incl. used oil disposal
- 33 11 ... Replacing rear cover gasket on rear differential (168L)
- 33 11 ... Replacing rear cover gasket on rear differential (188L / 188LW)
- 33 11 ... Replacing rear cover gasket on rear differential (215L / 215LW)
- 33 11 021 Replacing shaft seal for input flange on final drive
- 33 11 091 Replacing drive flange on left or right of rear differential
- 33 11 151 Replacing shaft seal for drive flange left or right
- 33 11 271 Replacing rear cover gasket on rear differential
- 17 Final drive mounting
- 21 Output shafts
- 33 21 ... Pressing output shaft out of drive flange and drawing in (output shaft removed from rear differential)
- 33 21 ... Ribbed teeth
- 33 21 001 Removing and installing or replacing left output shaft
- 33 21 002 Removing and installing / replacing right output shaft
- 33 21 035 Replacing gaiter on left output shaft (altered sealing cover)
- 33 21 036 Replacing gaiter on right output shaft
- 31 Rear sub-frame
- 32 Control arms and struts
- 33 32 021 Replacing left or right trailing arm
- 33 32 031 Replacing rubber mount for trailing arm in wheel carrier
- 33 32 035 Replacing a rubber mount for trailing arm in rear axle carrier
- 33 32 071 Replacing one upper control arm
- 33 32 091 Replacing a guide arm
- 33 32 125 Replacing a ball joint in lower steering knuckle/wheel carrier
- 33 32 131 Removing and installing / replacing a steering knuckle / wheel carrier
- 33 32 180 Removing and installing/replacing left or right toe arm
- 33 32 190 Removing and installing/replacing left or right camber arm
- 33 32 195 Replacing rubber mount for camber arm in rear axle carrier
- 51 75 001 Removing and installing/replacing left or right underbody cover
- 33 Axle mounting
- 41 Wheel bearings
- 33 41 005 Replacing left drive flange on rear axle shaft
- 33 41 007 Replacing right drive flange on rear axle shaft
- 33 41 153 Replacing wheel bearing (75 mm) on rear axle shaft on left
- 33 41 153 Replacing wheel bearing (85 mm) on rear axle shaft on left
- 33 41 155 Replacing right wheel bearing on rear axle shaft
- 52 Shock absorber
- 33 00 ... Information on replacing shock absorbers
- 33 52 000 Removing and installing / replacing rear left or right shock absorber
- 33 52 031 Replacing rear left or right rubber mount for shock absorber mounting
- 33 52 161 Replacing thrust bearing (lower section) for rear left or right spring strut/shock absorber
- 53 Springs with suspension
- 55 Stabilizer bar
- 90 Troubleshooting