LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2002 >> Excursion 7.3 F, RWD >> Repair and Diagnosis >> Electrical >> Gauges >> Instrument Panel - Analog -- Excursion & F250-F550 Super Duty >> Self-Diagnostic System >> Notes

Self-Diagnostic System: Notes

NOTE: This procedure DOES NOT cover Motorhomes.

Connect New Generation Star (NGS) or Worldwide Diagnostic System (WDS) tester to Data Link Connector (DLC). DLC is a 16-pin connector located below center of instrument panel. See Fig 1. Using NGS/WDS tester, perform data link diagnostic test. See DATA LINK DIAGNOSTIC TEST under SELF-DIAGNOSTIC SYSTEM in MODULE COMMUNICATIONS NETWORK - EXCURSION & F250-F550 SUPER DUTY PICKUPS article.

If NGS/WDS tester displays CKT70, CKT914 or CKT915 = ALL ECUS NO RESP/NOT EQUIP, diagnose module communications problem. See SELF-DIAGNOSTIC SYSTEM in MODULE COMMUNICATIONS NETWORK - EXCURSION & F250-F550 SUPER DUTY PICKUPS article.

If NGS/WDS tester displays NO RESP/NOT EQUIP for HEC, perform TEST A: NO SCAN TOOL COMMUNICATION WITH INSTRUMENT CLUSTER (HEC)  under SYSTEM TESTS.

If NGS/WDS tester displays SYSTEM PASSED, retrieve and record continuous DTCs. Erase continuous DTCs. See HYBRID ELECTRONIC INSTRUMENT CLUSTER MODULE DIAGNOSTIC TROUBLE CODE INDEX , RESTRAINT CONTROL MODULE DTC INDEX  and ABS CONTROL MODULE DTC INDEX  tables. If no instrument panel-related DTCs are retrieved, perform instrument cluster self-test. See INSTRUMENT CLUSTER SELF-TEST . If instrument cluster self-test is okay, repair by symptom. See SYMPTOM INDEX  table under SYSTEM TESTS. For DTCs not covered in this article, see MODULE COMMUNICATIONS NETWORK - EXCURSION & F250-F550 SUPER DUTY PICKUPS article.

HYBRID ELECTRONIC INSTRUMENT CLUSTER MODULE DIAGNOSTIC TROUBLE CODE INDEX

DTC (1) Description Perform Test
B1201 Fuel Sender Circuit Failure B 
B1204 Fuel Sender Circuit Short To Ground B 
B1317 Battery Voltage High D 
B1318 Battery Voltage Low D 
B1320 Driver Door Ajar Circuit Open R 
B1328 Passenger Door Ajar Circuit Open R 
B1342 ECU Defective (2)
B1360 Ignition Run/Acc Circuit Open A 
B2143 NVM Memory Failure A 
B2658 Wait To Start Indicator Circuit Open V 
C1284 Oil Pressure Sending Unit Failure E 
U1027 Invalid Or Missing Data For Engine RPM I 
U1051 Invalid Or Missing Data For Brakes K 
U1073 Invalid Or Missing Data For Engine Coolant F 
(1) Codes listed in this table are only for testing covered in this article. For HEC DTCs not covered in this article, see MODULE COMMUNICATIONS NETWORK - EXCURSION & F250-F550 SUPER DUTY PICKUPS article.
(2) Using NGS/WDS tester, clear DTCs. Retrieve DTCs. If B1342 is retrieved again, replace instrument cluster. See INSTRUMENT CLUSTER  under REMOVAL & INSTALLATION.
RESTRAINT CONTROL MODULE DTC INDEX

DTC (1) Description Perform Test
B1869 Air Bag Warning Indicator Lamp Circuit Open N 
B1870 Air Bag Warning Indicator Circuit Short To Voltage N 
(1) Codes listed in this table are only for testing covered in this article. For RCM DTCs not covered in this article, see AIR BAG RESTRAINT SYSTEMS article in RESTRAINTS.
ABS CONTROL MODULE DTC INDEX

DTC (1) Description Perform Test
C1226 Brake Warning Lamp Output Short To Ground J 
(1) Codes listed in this table are only for testing covered in this article. For ABS DTCs not covered in this article, see appropriate ANTI-LOCK article in BRAKES.
Fig 1: Identifying Data Link Connector Terminals
G99E08121Courtesy of FORD MOTOR CO.