Section 94 (Cables And Fuses - General Information)

WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.

Checking The Result Of The Crimping Operation (1999-2000)
- Examples of correct terminal crimping
- Examples Of Incorrect Crimping
Glossary (1999-2000)
- Glossary for connector/housings
- Terms used for cable terminals
Ground Points And Oxidation (1999-2000)
- Ground points and oxidation
Inserting A Cable Terminal In A Housing (1999-2000)
- Closing the housing
  - Keep in mind the following
  - After completing the repair work
- When cable terminal is to be inserted in a housing
  - Keep in mind the following
  - Proceed
Open The Connector (1999-2000)
Operating Procedures For Repairs (1999-2000)
- Proceed as follows
Replacing Cable Terminals (1999-2000)
- New cable terminal
- Seal SWS and plug
  - Seal SWS for cable terminals
  - Plug
Soldering, General (1999-2000)
- Soldering, general
Stripping A Cable (1999-2000)
- Cutting and checking a cable
  - Cutting a cable
  - Inspect the cable insulation
- Stripping the cable
  - Stripping the cable for a cable terminal
  - Length of the stripped section of cable
Terminal Crimping (1999-2000)
Cables (1999-2006)
- Cable terminals surface treatment
  - General information