Section 6 (Engine Mechanical - 1.8L (LV6))
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Engine Mechanical
- Symptoms - Engine Mechanical
- Base Engine Misfire without Internal Engine Noises
- Base Engine Misfire with Abnormal Internal Lower Engine Noises
- Base Engine Misfire with Abnormal Valve Train Noise
- Base Engine Misfire with Coolant Consumption
- Base Engine Misfire with Excessive Oil Consumption
- Engine Noise on Start-Up, but Only Lasting a Few Seconds
- Upper Engine Noise, Regardless of Engine Speed
- Lower Engine Noise, Regardless of Engine Speed
- Engine Noise Under Load
- Engine Compression Test
- Cylinder Leakage Test
- Oil Consumption Diagnosis
- Oil Pressure Diagnosis and Testing
- Oil Leak Diagnosis
- Crankcase Ventilation System Inspection/Diagnosis
- Drive Belt Chirping Diagnosis
- Drive Belt Squeal Diagnosis
- Drive Belt Whine Diagnosis
- Drive Belt Rumbling Diagnosis
- Drive Belt Vibration Diagnosis
- Drive Belt Falls Off Diagnosis
- Drive Belt Excessive Wear Diagnosis
- Repair Instructions
- On-Vehicle Repair Instructions
- Drive Belt Replacement
- Drive Belt Tensioner Replacement
- Engine Cover Replacement
- Engine Support Fixture
- Engine Mount Inspection
- Engine Mount Replacement
- Oil Level Indicator and Tube Replacement
- Oil Filter Adapter and Bypass Valve Assembly Replacement
- Positive Crankcase Ventilation (PCV) Valve Replacement
- Engine Block Heater Replacement
- Intake Manifold Replacement
- Intake Camshaft and Lifter Replacement
- Exhaust Camshaft and Lifter Replacement
- Valve Lash Adjustment
- Crankshaft Pulley Replacement
- Crankshaft Front Oil Seal Replacement
- Timing Chain Tensioner Replacement
- Timing Chain and Sprockets Replacement
- Camshaft Actuator Locking Pin Adjustment
- Timing Chain Housing Replacement
- Cylinder Head Cover Replacement
- Cylinder Head Replacement
- Oil Pan Replacement
- Oil Pump Replacement
- Crankshaft Rear Oil Seal Replacement
- Engine Flywheel Replacement
- Engine Replacement
- Engine Oil and Oil Filter Replacement
- Off-Vehicle Repair Instructions
- Draining Fluids and Oil Filter Removal
- Engine Flywheel Removal
- Oil Level Indicator and Tube Removal
- Exhaust Manifold Removal
- Intake Manifold Removal
- Crankshaft Pulley Removal
- Cylinder Head Cover Removal
- Water Pump Removal
- Timing Chain Tensioner Removal
- Timing Chain Housing Removal
- Timing Chain and Sprockets Removal
- Intake Camshaft and Lifter Removal
- Exhaust Camshaft and Lifter Removal
- Cylinder Head Removal
- Oil Filter Adapter Removal
- Oil Pan Removal
- Oil Pump Removal
- Piston, Connecting Rod, and Bearing Removal
- Crankshaft Rear Oil Seal Removal
- Crankshaft and Bearings Removal
- Engine Block Cleaning and Inspection
- Crankshaft Pulley Cleaning and Inspection
- Engine Flywheel Cleaning and Inspection
- Cylinder Boring and Honing
- Crankshaft and Bearings Cleaning and Inspection (Crankshaft and Bearing Inspect)
- Crankshaft and Bearings Cleaning and Inspection (Bearing Selection)
- Piston and Connecting Rod Disassemble
- Piston, Connecting Rod, and Bearings Cleaning and Inspection (Connecting Rod Bearing Inspect)
- Piston, Connecting Rod, and Bearings Cleaning and Inspection (Bearing Selection)
- Piston and Connecting Rod Assemble
- Camshafts Cleaning and Inspection
- Valve Lifters and Guides Cleaning and Inspection
- Timing Chain and Sprockets Cleaning and Inspection
- Cylinder Head Disassemble
- Cylinder Head Cleaning and Inspection
- Valve Guide Reaming/Valve and Seat Grinding
- Cylinder Head Assemble
- Oil Pump Disassemble
- Oil Pump Cleaning and Inspection
- Oil Pump Assemble
- Intake Manifold Cleaning and Inspection
- Exhaust Manifold Cleaning and Inspection
- Oil Pan Cleaning and Inspection
- Thread Repair
- Service Prior to Assembly
- Crankshaft and Bearings Installation
- Crankshaft Rear Oil Seal Installation
- Piston, Connecting Rod, and Bearing Installation
- Oil Pump Installation
- Cylinder Head Installation
- Intake Camshaft and Lifter Installation
- Exhaust Camshaft and Lifter Installation
- Timing Chain and Sprockets Installation
- Timing Chain Housing Installation
- Timing Chain Tensioner Installation
- Water Pump Installation
- Crankshaft Front Oil Seal Installation
- Cylinder Head Cover Installation
- Oil Pan Installation
- Oil Filter Adapter Installation
- Intake Manifold Installation
- Crankshaft Pulley Installation
- Exhaust Manifold Installation
- Oil Level Indicator and Tube Installation
- Engine Flywheel Installation
- On-Vehicle Repair Instructions
- Description and Operation
- Special Tools and Equipment