Section 98 (Steering And Wheel Alignment - Repair - S Clubman (R55))

• Electronic Chassis Alignment
  • 00 Danger of poisoning if oil is ingested/absorbed through the skin
  • 00 Risk of injury if oil comes into contact with eyes and skin
  • 00 Safety instructions for handling oil
  • 00...... Raising vehicle with trolley jack
  • 31 00... Front axle + steering: wheel/chassis alignment check must be carried out after the following work
  • 32...... Overview of steering
  • 32 00... Chassis/wheel alignment check procedure
  • 32 00... General chassis and suspension definitions
  • 32 00... General information and definitions
  • 32 00... Identification of suspension without label
  • 32 00... Information on replacing steering gear after accident damage
  • 32 00... Moving vehicle into design position
  • 32 00... Moving vehicle into normal position
  • 32 00... Performing rim runout compensation
  • 32 00... Test conditions for chassis/wheel alignment check
  • 32 00 150 KDS chassis/wheel alignment check with load up to design position
  • 32 00 155 KDS chassis/wheel alignment check with ride-height measurement without load
  • 32 00 601 Adjusting toe-in on front axle
  • 32 00 610 Adjusting toe-in and camber on front axle
  • 32 00 620 Adjusting rear axle
  • 33 00... Rear axle: wheel/chassis alignment check must be carried out after the following work
  • 51 71 505 Mount securing fixture for vehicle on lifting platform
  • 61 31 996 Carry out steering angle sensor adjustment
• Mechanical Steering Gear
  • 32 00... Information on replacing steering gear after accident damage
  • 32 11... Instructions for removing and installing ear clips
  • 32 11 100 Replacing gaiter for steering gear on left or right
  • 32 21 151 Replacing left or right tie rod
  • 32 21 231 Replacing (removing and installing) left or right tie rod
• Steering Gear With Servo Unit
  • 32 00... Information on replacing steering gear after accident damage
  • 32 11 100 Replacing gaiter for steering gear on left or right
  • 32 13 070 Removing and installing (replacing) electric steering gear (EPS)
  • 32 21 151 Replacing left or right tie rod
  • 32 21 231 Replacing (removing and installing) left or right tie rod
• Steering Arms, Tie Rod
  • 32 11 100 Replacing gaiter for steering gear on left or right
  • 32 21 151 Replacing left or right tie rod
  • 32 21 231 Replacing (removing and installing) left or right tie rod
• Steering Column
  • 32 31... Removing and installing/replacing steering column lock
  • 32 31 004 Removing and installing / replacing upper section of steering column trim
  • 32 31 020 Removing and installing / replacing lower section of steering column trim
  • 32 31 082 Removing and installing/replacing steering angle sensor
  • 32 31 090 Removing and installing/replacing steering column
• Steering Wheel
  • 32 33... Replacing lower sport steering wheel trim
  • 32 33... Replacing spoke covers for steering wheel
  • 32 33 010 Removing and installing/replacing sport steering wheel/steering wheel
• Steering Wheel For Airbag
  • 32 34 020 Removing and installing/replacing airbag unit
  • 32 34 030 Removing and installing/replacing airbag unit (sport steering wheel)
  • 72 00... Safety regulations for handling components with gas generators
  • 72 12... Procedure after airbag triggering as result of an accident
• Electronic Power Steering
  • 32 43 550 Replace EPS unit
• Troubleshooting
  • 32 90... Troubleshooting on electric steering gear (EPS)
  • 32 90... Troubleshooting on steering