Section 985 (Heating And Air Conditioning - Repair -- F31)
WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2016 BMW 328i xDrive, 2016 BMW 328d xDrive, 2015 BMW 328i xDrive, 2015 BMW 328d xDrive, and 2014 BMW 328i xDrive. However, it is still accessible from the selected car via links, so may be relevant.
- Note, Overview Components Climate Control
- Heater With Operation
- 64 11... Installing servodrive
- 64 11.. Overview of actuator drives on heater/air conditioner
- 64 00.. Overview of heater - A/C system components
- 61 35 275 Remove and install (replace) control unit Rear Electronic Module (REM)
- 64 11 380 Removing and installing/replacing control unit for air conditioning
- 64 11 377 Removing and installing control panel of heater/air conditioning system
- 61 31 321 Removing and installing radio and A/C control panel
- 64 11 866 Removing and installing/replacing actuator drive for blending flap (left)
- 64 11 872 Removing and installing/replacing actuator drive for blending flap (right)
- 64 11 868 Removing and installing/replacing actuator drive for defrosting flap
- 64 11 806 Removing and installing/replacing actuator drive for fresh/recirculated air flap
- 64 11 908 Removing and installing/replacing footwell temperature sensor (left)
- 64 11 908 Removing and installing/replacing footwell temperature sensor (right)
- 64 11 213 Removing and installing/replacing heating and air conditioning blower
- 64 11 206 Removing and installing/replacing heating and air-conditioning unit (N20, N26)
- 64 11 206 Removing and installing/replacing heating and air-conditioning unit (N47)
- 64 11 991 Removing and installing/replacing sensor for automatic recirculated air control (AUC)
- 64 11 891 Replace control panel for heater/air conditioning system
- 64 11 832 Replace the actuator drive for the ventilation flap, right (High A/C system)
- 64 11 835 Replacing actuator drive for left blending flap
- 64 11 830 Replacing actuator drive for left ventilation flap (High A/C system)
- 64 11 850 Replacing actuator drive for rear compartment flap
- 64 11 837 Replacing actuator drive for right stratification flap
- 64 11... Replacing condensation water drain hose of heating and air conditioning system
- 64 11 225 Replacing controller for heating and air conditioning system blower
- 64 11 943 Replacing evaporator temperature sensor
- 64 11 208 Replacing heat exchanger
- 64 11... Replacing retaining ring for condensation drain hose
- Auxiliary. Heater With Control Elements
- Nozzles And Outlets
- 64 00.. Overview of heater - A/C system components
- 64 22 125 Removing and installing (replacing) right fresh air grille
- 64 22 115 Removing and installing left fresh air grille
- 64 22 165 Removing and installing/replacing center fresh air grille
- 64 22 191 Removing and installing/replacing rear cabin fresh air grille (High A/C system)
- 64 22 118 Replace fresh air grille, left
- MICROFILTER
- Air Conditioning, Leak Detection
- 64 50... A/C performance test
- 64 50 010 Drawing off, evacuating and filling heating and air conditioning system (R134a)
- 64 50 010 Extract, evacuate and fill air conditioning system
- 64 52... Instructions for opening and part replacement in refrigerant circuit
- 64 53... Instructions for replacement of air conditioning capacitors and radiator/coolers
- 64 50... Leak detection with forming gas
- 64 50... Leak detection with ultraviolet additives (UV additives) (BMW leak-testing case)
- 64 50... Note for handling R134a refrigerant
- 64 00.. Overview of heater - A/C system components
- 64 50... Safety informations for handling refrigerant oil
- 64 50... Safety informations for handling tetrafluorethane refrigerant R134a
- Ac Housing/Evaporator, Switching Elements
- 64 51 001 Cleaning the evaporator (left-hand drive vehicle)
- 64 52... Instructions for opening and part replacement in refrigerant circuit
- 64 51... Leak-testing evaporator
- 64 00.. Overview of heater - A/C system components
- 64 51 591 Removing and installing/renewing evaporator
- 64 51 520 Removing and installing/replacing expansion valve (N20, N26)
- 64 51 520 Removing and installing/replacing expansion valve (N47)
- Compressor
- 64 52... Instructions for opening and part replacement in refrigerant circuit
- 64 52... Notes for changing the air conditioning compressor (amount of refrigerant oil of new air conditioning compressor known)
- 64 52... Notes for changing the air conditioning compressor (amount of refrigerant oil of new air conditioning compressor not known)
- 64 00.. Overview of heater - A/C system components
- 64 52 523 Replacing A/C system compressor (N20, N26)
- 64 52 523 Replacing air conditioning compressor (N47)
- Condenser And Dryer With Lines
- 64 53... Instructions for desiccant insert replacement
- 64 52... Instructions for opening and part replacement in refrigerant circuit
- 64 53... Instructions for replacement of air conditioning capacitors and radiator/coolers
- 64 00.. Overview of heater - A/C system components
- 64 53 551 Removing and installing/replacing capacitor (with desiccant insert) for heating and air conditioning system
- 64 53 520 Replacing safety pressure switch