Section 125 (Engine Control Module (ECM), Fuel Pump - Removal & Installation (Coupe))
WARNING: This page is about a different car, the 2002 Volvo C70, 2001 Volvo C70, 2000 Volvo C70, 1999 Volvo C70, and 1998 Volvo C70. However, it is still accessible from the selected car via links, so may be relevant.
- Engine Fuel
- Fuel Pump Unit, Replacing
- Notes
- Safety
- Preparation
- Removing the luggage compartment floor
- Unplugging the connectors
- Detaching the filler pipe
- Disconnecting the rear wheels
- Disconnecting the fuel tank EVAP lines
- Removing the protective covers in front of fuel tank
- Removing the exhaust pipe
- Detaching the longitudinal stay mountings
- Removing the hand brake cable
- Removing the propeller shaft
- Standard bolts for front and rear CV joints and balancer bolt for rear CV joint
- Lowering the torque tube
- Removing the rear suspension assembly
- Fitting the fuel pump units
- Fitting the rear suspension assembly
- Fitting the fuel lines
- Removing Fuel Line From Fuel Pump
- Fitting the fuel lines to the clips
- Fitting the hand brake cable
- Raising the rear suspension with fuel tank
- Fitting the retaining bolts for the rear axle member.
- Tightening the tank strap attachments
- Fitting the fuel tank EVAP lines
- Fitting the propeller shaft and driver
- Fitting the longitudinal stay mountings and jack attachments
- Fitting the exhaust pipe
- Fitting the filler pipe
- Fitting the hatches and connections to the tank fitting
- Positioning the luggage compartment floor mountings
- Fitting the rear wheels
- Fuel Pump Unit, Replacing
- Engine Control Module