41 14 021 Stripping Operations - Replacing Front Left Wheel Arch (Non-Hybrid)

WARNING: This page does not describe the selected car, but rather 50 other vehicles, including the 2016 BMW M5, 2016 BMW ActiveHybrid 5, 2016 BMW 550i xDrive, 2016 BMW 550i, and 2016 BMW 535i xDrive. However, it is still accessible from the selected car via links, so may be relevant.

NOTE: Owing to the different engine variants and equipment specifications, not all the components are taken into consideration.
The following list basically represents the removal sequence.

Disconnect negative battery cable (61 20 900 )
Remove bumper trim (51 11 156 )
Remove bumper support (51 11 050 )
Remove headlight (63 12 010 or 63 12 010 From 07/13)
Remove radiator. Refer to:
For N20: 17 11 000

For N52: 17 11 000

For N55: 17 11 000

For N57 Diesel: 17 11 000

For N63: 17 11 000

For S63: 17 11 000
Remove A/C system condenser (64 53... )
Remove and install charge air cooler. Refer to:
For N52: 17 11 000

For N55: 17 51 000

For N57 Diesel: 17 51 000

For N63: Left-17 51 001 . Right-17 51 001

For S63: Left-17 51 001 . Right-17 51 001
Remove hydraulic steering cooling coil. Refer to:
For N55: 17 11 370

For N57 Diesel: 17 11 370

For N63: 17 11 370

For S63: 17 11 370
Remove intake silencer housing
Remove coolant expansion tank. Refer to:
For N20: 17 11 100

For N52: 17 11 100

For N55: 17 11 100

For N57 Diesel: 17 11 100

For N63: 17 11 100

For S63: 17 11 100
Remove wheel arch cover (front section) (51 71 038 )
Remove wheel arch cover (rear section) (51 71 039 )
Front axle complete with engine and transmission. (FRONT AXLE SUSPENSION )
Engine compartment lid seal locator (51 76 035 ).
Remove engine compartment lid (41 61 000 )
Remove engine compartment lid hinge
Remove left side wall
Remove top left wishbone. Refer to:
For M5: 31 12 002

For All Other Models: 31 12 002
Remove left suspension brace (51 71 345 )
Remove bulkhead sound insulation
Remove brake booster (34 33 505 )
Remove/detach hydraulic lines for power steering pump.
Detach coolant hoses
Detach fuel lines
Release left wiring harness
Partially release/remove thermal protection