Body Equipment - Repair - E60

General
- 51 00.. Overview of front door
- 51 00.. Overview of rear door
- 51 00... Notes on bonding/attaching components with double-sided adhesive tape
- 51 00... Notes on fitting window guide seals
- 51 00... Safety instructions for working on cars with airbag systems
- 51 00... Service position of engine compartment lid
Front Bumper
- 51 11... Overview of front bumper
- 51 11... Installing/replacing license plate (without base)
- 51 11... Removing and installing/replacing cover for headlight washer unit on left
- 51 11... Removing and installing/replacing front fog lamp trim (M aerodynamic kit)
- 51 11 050 Removing and installing/replacing carrier for front bumper trim
- 51 11 156 Removing and installing front bumper trim
- 51 11 157 Replacing front bumper trim
- 51 11 158 Replacing baseplate for license plate
- 51 11 160 Removing and installing/replacing trim for air duct on bumper trim (up to 03/2007)
- 51 11 160 Removing and installing/replacing trim for air duct on bumper trim (from 03/2007)
- 51 11 180 Removing and installing/replacing grille in bumper trim (M5 or M aerodynamic kit)
- 51 11 180 Removing and installing/replacing trim grille in bumper trim (up to 03/2007)
- 51 11 180 Removing and installing/replacing trim grille in bumper trim (from 03/2007)
- 51 11 181 Removing and installing/replacing finisher rod on trim grille for front bumper trim
- 51 11 701 Replacing left or right bracket for front bumper
Rear Bumper
- 51 12... Overview of rear bumper
- 51 12... Removing and installing/replacing diffuser on rear bumper trim (M Technic aerodynamic kit)
- 51 12 050 Removing and installing/replacing carrier for rear bumper trim
- 51 12 156 Removing and installing rear bumper trim
- 51 12 157 Replacing rear bumper trim
- 51 12 801 Replacing bracket for rear bumper at left or right
- 51 12 810 Removing and installing / replacing deformation element on bumper carrier on left or right
- 51 12 826 Removing and installing/replacing guide for rear bumper
- 51 12 827 Removing and installing / replacing guide for bottom rear bumper
Trim, Covers, Handle Trim
- 51 13... Replacing front radiator grille, middle left or right
- 51 13 001 Removing and installing/replacing front radiator grille, middle left or right
- 51 13 115 Removing and installing/replacing cowl panel cover
- 51 13 280 Removing and installing trim strip on roof frame at left or right
BMW Emblems, Model Emblems
- 51 14...General notes for labelling with adhesive films
- 51 14... Instructions for attaching number/letter designation combination
- 51 14 000 Removing and installing/replacing front BMW badge
- 51 14 010 Removing and installing/replacing rear BMW badge
- 51 14 110 Removing and installing/replacing rear model designation
- 51 14 110 Removing and installing/replacing rear model designation (Brilliance)
Mirrors, Covers, Ashtrays, Shelves, Trays
- Main-beam assistant diagnosis: E60, E61, E63, E64, E65, E66, E90, E91, E92, E93, E70
- 51 16.. Overview of storage compartment (center console)
- 51 16... Gluing of mirror base
- 51 16... Removing and installing / replacing front insert (on storage compartment trim)
- 51 16... Removing and installing/replacing center armrest
- 51 16... Removing and installing/replacing center armrest adjustment unit
- 51 16... Removing and installing/replacing center console cover
- 51 16... Removing and installing/replacing driver's side storage compartment
- 51 16... Removing and installing/replacing finisher for storage tray at rear
- 51 16... Removing and installing/replacing front inner cup holder carrier
- 51 16... Removing and installing/replacing front outer cup holder carrier
- 51 16... Removing and installing/replacing rear insert (in storage compartment)
- 51 16 000 Removing and installing/replacing mirror on left or right front door
- 51 16 026 Replacing mirror glass
- 51 16 040 Removing and installing/replacing housing on left or right door mirror
- 51 16 045 Removing and installing/replacing retaining ring on left or right door mirror
- 51 16 060 Removing and installing/replacing interior rearview mirror (overview)
- 51 16 060 Removing and installing/replacing interior rearview mirror (with Autobeam/high-beam assistant)
- 51 16 060 Removing and installing/replacing interior rearview mirror (with Japanese inside mirror with electronic toll function)
- 51 16 060 Removing and installing/replacing interior rearview mirror (with mirror arm end caps)
- 51 16 060 Removing and installing/replacing interior rearview mirror (with rain sensor)
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 155 Replacing locator for front ashtray insert (from 03/2007)
- 51 16 155 Replacing locator for front ashtray insert (up to 03/2007)
- 51 16 200 Removing and installing storage compartment
- 51 16 201 Replacing storage compartment
- 51 16 202 Removing and installing/replacing front (inner or outer) cup holder
- 51 16 204 Removing and installing/replacing cup holder in armrest for rear seat backrest
- 51 16 210 Removing and installing/replacing trim for preselector lever (from 03/2007)
- 51 16 210 Removing and installing/replacing trim for preselector lever (up to 03/2007)
- 51 16 211 Removing and installing/replacing finisher for storage tray
- 51 16 253 Removing and installing/replacing infrared trim (long version)
- 51 16 255 Removing and installing drawer in rear console (long version)
- 51 16 263 Removing and installing upper rear console trim (long version)
- 51 16 268 Removing and installing lower rear console trim (long version)
- 51 16 270 Removing and installing rear console at rear (long version)
- 51 16 325 Removing and installing/replacing fastener for center armrest
- 51 16 340 Removing and installing/replacing lock for right glovebox
- 51 16 342 Removing and installing/replacing lock cylinder for passenger airbag deactivation
- 51 16 360 Removing and installing/replacing right glovebox
- 51 16 366 Removing and installing right glovebox with housing
- 51 16 400 Removing and installing/replacing roller sun blind on fixed side window of left or right rear door
- 51 16 405 Removing and installing/replacing roller sun blind on side window of left or right rear door (up to 03/2007)
- 51 16 405 Removing and installing/replacing roller sun blind on side window of left or right rear door (long version or from 03/2007)
- 51 16 450 Removing and installing/replacing rear left/right grab handle
- 51 16 480 Removing and installing or replacing front grab handle
- 51 16 992 Disassembling and assembling lock cylinder (lock cylinder removed)
  - Necessary preliminary tasks
Lids
- 51 17 400 Removing and installing/replacing bump stop with ejector for filler flap
Front Door Locks, Handles, Fittings
- 51 21... Removing window cavity cover strip with special tool 00 9 324 at front or rear
- 51 21... Overview of front door locks
- 51 21 003 Replacing door detent (lock striker), front left or right
- 51 21 004 Adjusting front left or right door detent (lock wedge)
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 125 Removing and installing/replacing carrier for left or right outside door handle with lock cylinder
- 51 21 126 Removing and installing/replacing carrier for left or right outside door handle without lock cylinder
- 51 21 140 Removing and installing/replacing complete lock cylinder in left or right front door
- 51 21 150 Blocking, if necessary initializing, car key in immobilizer control module
- 51 21 170 Removing and installing or replacing outside handle from left or right front door
- 51 21 180 Removing and installing/replacing cover on outside handle
- 51 21 200 Removing and installing/replacing outside handle and lock actuation of left or right front door
- 51 21 225 Removing and installing/replacing inside door opener for left or right front door (up to 03/2007)
- 51 21 225 Removing and installing/replacing inside door opener for left or right front door (long version or from 03/2007)
- 51 21 233 Removing and installing/replacing Bowden cable for outside door handle on left or right front door
- 51 21 235 Removing and installing/replacing Bowden cable for inside door opener on left or right front door
- 51 21 280 Removing and installing or replacing door brake on left or right front door
- 51 21 300 Removing and installing or replacing window cavity cover strip on outside of left or right front door
- 51 21 330 Removing and installing/replacing window cavity cover strip on inner front door
- 51 21 360 Replacing seal for door seam/roof frame on left or right front door
- 51 21 370 Removing and installing/replacing cover (seal) on front door at bottom left or right
Rear Door Locks, Handles, Fittings
- 51 22... Overview of rear door locks
- 51 22... Removing and installing/replacing side impact protection in left or right rear door
- 51 22 001 Replacing door detent (lock striker), rear left or right
- 51 22 004 Adjusting rear left or right door detent
- 51 22 090 Removing and installing/replacing door lock in left or right rear door
- 51 22 126 Removing and installing/replacing carrier for outside door handle on left or right rear door
- 51 22 170 Removing and installing / replacing outside handle on left or right rear door
- 51 22 180 Removing and installing/replacing cover on outside handle
- 51 22 225 Removing and installing/replacing inside door opener of rear left or right door
- 51 22 233 Removing and installing/replacing Bowden cable for outside door handle on left or right rear door
- 51 22 235 Removing and installing/replacing Bowden cable for inside door opener on left or right rear door
- 51 22 280 Removing and installing/replacing door retainer on rear left or right door
- 51 22 300 Removing and installing/replacing window cavity cover strip on rear door on left or right
- 51 22 330 Removing and installing/replacing window cavity cover strip on inside rear door
- 51 22 360 Replacing seal for door seam/roof frame on left or right rear door
- 51 22 370 Removing and installing/replacing cover at bottom left or right on rear door
Engine Compartment Lid Latch Locks
- 51 23... Removing/installing ball sockets with clip
- 51 23... Adjusting/replacing bump stops
- 51 23 004 Adjusting engine compartment lid catch
- 51 23 100 Removing and installing/replacing right engine compartment lid lock
- 51 23 110 Removing and installing/replacing left engine compartment lid lock
- 51 23 131 Adjusting left or right striker on engine compartment lid
- 51 23 160 Removing and installing/replacing arrester hook on engine compartment lid
- 51 23 211 Removing and installing/replacing cable for front engine compartment lid locks (to passenger compartment)
- 51 23 212 Removing and installing/replacing cable for front engine compartment lid locks (to locks)
- 51 23 265 Removing and installing/replacing left or right gas strut for engine compartment lid
Trunk Latch Locks
- 51 24 004 Adjusting rear lid lock (lower section of rear lid lock)
- 51 24 050 Removing and installing/replacing lock element (lock cylinder) for rear lid
- 51 24 100 Removing and installing/replacing rear lid lock (upper section)
- 51 24 130 Removing and installing/replacing striker for rear lid lock
- 51 24 145 Removing and installing/replacing button for rear lid actuation
- 51 24 325 Removing and installing/replacing left tension spring for rear lid
- 51 24 326 Removing and installing / replacing left tension spring with damper for rear lid
- 51 24 391 Replacing rubber mount on trunk lid support
Front And Rear Window
- 51 31... Notes on window bonding; work steps for removing and installing window glass
- 51 31... Removing windscreen with "Roll Out 2000"
- 51 31... Removing windows with an oscillating knife
- 51 31... Window glass removal with wire pull handle
- 51 31... Instructions for repairing stone-chipped laminated safety glass windscreens (clear and tinted)
- 51 31... Repair instructions for laminated safety glass
- 51 31 000 Removing and installing/replacing windscreen
- 51 31 015 Repairing damage to windscreens caused by pitting (stone chips) (clear and tinted laminated safety glass)
- 51 31 021 Removing and installing / replacing rubber frame for windscreen (top)
- 51 31 030 Removing and installing or replacing left or right gutter strip along windscreen
- 51 31 200 Removing and installing/replacing rear window
- 51 31 231 Replacing rear window (complete rear window)
- 51 31 241 Replacing rubber frame (top/side) for rear window
- 51 31 242 Replacing rubber frame (bottom) for rear window
Front Manually Operated Windows
- 51 32 154 Adjusting left or right front door window
- 51 32 160 Removing and installing/replacing housing cover on inner left or right door window frame
- 51 32 170 Removing and installing/replacing door window glass, front left or right
- 51 32 211 Replacing front left or right rubber guide for left or right door window
- 51 32 390 Removing and installing / replacing decorative strip on front left or right door
- 51 32 420 Removing and installing/replacing trim on front door window frame, left or right
Front Electrically Operated Windows
- 51 33 000 Removing and installing (replacing) power window unit in left or right front door
Rear Manually Operated Windows
- 51 34... Removing and installing/replacing trim for window guide of left or right rear door
- 51 34 160 Removing and installing/replacing housing cover on inner left or right door window frame
- 51 34 171 Replacing rear left or right door window
- 51 34 191 Replacing left or right fixed door window in rear window frame
- 51 34 211 Replacing rubber guide for rear left or right door window
- 51 34 380 Removing and installing/replacing decorative strip on rear door (top), left or right
- 51 34 420 Removing and installing/replacing trim on window frame of rear door (front), left or right
Electrical Power Windows, Body
- 51 37 000 Removing and installing complete rear left or right power window unit
Front Door Trim Panel With Arm Rest
- 51 41... Replacing door pocket on front left or right door trim panel
- 51 41 000 Removing and installing front left or right door trim panel (long version or from 03/2007)
- 51 41 000 Removing and installing front left or right door trim panel (up to 03/2007)
- 51 41 001 Replacing front left or right door trim panel (up to 03/2007)
- 51 41 001 Replacing front left or right door trim panel (long version or from 03/2007)
- 51 41 017 Removing and installing/replacing cover on door handle, front left or right
- 51 41 018 Replacing speaker trim on front left or right door trim panel (long version or from 03/2007)
- 51 41 019 Removing and installing/replacing door handle on front left or right door trim panel (up to 03/2007)
- 51 41 019 Removing and installing/replacing door handle on front left or right door trim panel (long version or from 03/2007)
- 51 41 025 Replacing handle recess on front left or right door trim panel (long version or from 03/2007)
- 51 41 030 Removing and installing/replacing decorative strip on front left or right door trim panel (long version or from 03/2007)
- 51 41 060 Removing and installing/replacing armrest on front left or right door trim panel (up to 03/2007)
- 51 41 081 Replacing armrest on front left or right door trim panel (long version or from 03/2007)
Rear Door Trim Panel With Arm Rest
- 51 42... Removing and installing/replacing door pocket on rear left or right door trim panel (up to 03/2007)
- 51 42 000 Removing and installing rear left or right door trim panel (up to 03/2007)
- 51 42 000 Removing and installing rear left or right door trim panel (long version or from 03/2007)
- 51 42 001 Replacing rear left or right door trim panel (up to 03/2007)
- 51 42 001 Replacing rear left or right door trim panel (long version or from 03/2007)
- 51 42 017 Removing and installing/replacing cover on door handle, rear left or right
- 51 42 018 Replacing speaker trim on rear left or right door trim panel (long version or from 03/2007)
- 51 42 019 Removing and installing/replacing door handle on rear left or right door trim panel (up to 03/2007)
- 51 42 019 Removing and installing/replacing door handle on rear left or right door trim panel (long version or from 03/2007)
- 51 42 030 Removing and installing/replacing decorative strip on rear left or right door trim panel (long version or from 03/2007)
- 51 42 060 Removing and installing/replacing armrest on rear left or right door trim panel (up to 03/2007)
- 51 42 081 Replacing armrest on rear left or right door trim panel (long version or from 03/2007)
Side Covering With Armrests
- 51 43 070 Removing and installing/replacing side trim panel, footwell, on A-pillar, left
- 51 43 075 Removing and installing / replacing side trim panel, footwell, on A-pillar, right
- 51 43 148 Removing and installing or replacing trim on left or right door pillar (top)
- 51 43 150 Removing and installing or replacing trim for left or right door pillar (bottom)
- 51 43 201 Removing and installing/replacing panel for roof pillar at front (A-pillar), left or right
- 51 43 251 Removing and installing/replacing trim for rear left or right roof pillar (rear)
- 51 43 255 Removing and installing/replacing trim for rear left or right roof pillar (front)
Roof Trim Panel
- 51 44... Removing and installing front roofliner trim
- 51 44 001 Removing and installing/replacing headliner (without slide/tilt sunroof)
- 51 44 011 Removing and installing / replacing headliner (with slide / tilt sunroof)
- 51 44 011 Removing and installing/replacing roofliner (long version with slide/tilt sunroof)
- 51 44 180 Removing and installing/replacing rear console insert/make-up mirror in rear cabin (long version)
Instrument Cluster Trim Panel
- 51 45... Overview of instrument panel
- 51 45... Removing and installing/replacing trim on ashtray
- 51 45 030 Removing and installing instrument panel trim
- 51 45 031 Replacing instrument panel trim
- 51 45 115 Removing and installing speaker frame on panel for instrument panel at top
- 51 45 181 Removing and installing/replacing bottom right trim for instrument panel
- 51 45 185 Removing and installing/replacing panel for pedals
- 51 45 310 Removing and installing (replacing) center instrument panel trim (from 03/2007)
- 51 45 310 Removing and installing (replacing) center instrument panel trim (up to 03/2007)
- 51 45 314 Removing and installing/replacing center (bottom) instrument panel trim
- 51 45 370 Removing and installing (replacing) left decorative strip on instrument panel
- 51 45 380 Removing and installing (replacing) right decorative strip on instrument panel
Parcel Shelf Trim Panel, Roller Sun Blind
- 51 46 001 Removing and installing trim for oddments tray (back shelf with rear window roller blind)
- 51 46 002 Replacing trim for oddments tray (back shelf with rear window roller blind)
- 51 46 006 Removing and installing/replacing trim for rear parcel shelf
- 51 46 013 Removing and installing/replacing rear window roller blind
- 51 46 050 Removing and installing/replacing top trim on rear apron
Floor, Luggage, Engine Compartment Trim Panels
- 51 47... Removing and installing/replacing left or right underbody panelling
- 51 47 000 Removing and installing/replacing front (inside) left or right entrance cover strip
- 51 47 030 Removing and installing/replacing rear (inside) left or right entrance cover strip
- 51 47 065 Removing and installing / replacing finishing strip at front left or right entrance
- 51 47 072 Removing and installing/replacing finishing strip at rear left or right entrance
- 51 47 101 Removing and installing/replacing luggage compartment floor trim panel
- 51 47 151 Removing and installing/replacing left luggage compartment wheel arch trim
- 51 47 161 Removing and installing/replacing right luggage compartment wheel arch trim
- 51 47 210 Removing and installing/replacing trunk trim panel on left side panel
- 51 47 220 Removing and installing/replacing trunk trim panel on right side panel
- 51 47 305 Removing and installing/replacing stowage net in front footwell
- 51 47 312 Replacing footrest for front passenger compartment
- 51 47 315 Removing and installing / replacing front carpet for passenger compartment
- 51 47 440 Removing and installing/replacing rear carpet on seat pan
- 51 47 490 Removing and installing / replacing front underbody protection
- 51 47 491 Removing and installing/replacing rear underbody protection
Front Lid Insulation Lining
- 51 31... Notes for bonding sound insulation (SI), doors
- 51 48 001 Removing and installing/replacing insulation lining on engine compartment lid
- 51 48 060 Removing and installing/replacing sound insulation in left or right front door
- 51 48 070 Removing and installing/replacing sound insulation on left or right rear door
Rear Lid Trim Panel
- 51 49 000 Removing and installing or replacing trim for rear lid
Gaskets/Seals, Loose Body Parts
- 51 71... Removing and installing/replacing (lower) front wheel arch cover on right
- 51 71 000 Removing and installing/replacing seal on front door, left or right
- 51 71 040 Removing and installing/replacing front left or right wheel arch cover
- 51 71 041 Removing and installing/replacing rear left or right wheel arch cover
- 51 71 200 Removing and installing/replacing seal on rear door, left or right
- 51 71 373 Removing and installing/replacing tension strut on spring strut dome
- 51 71 407 Replacing rear spoiler (M5)
- 51 71 447 Removing and installing or replacing panel for cover on left or right side member
MUCKET For Doors
- 51 70... Fitting seals