Section 10 (Final Drive, Differential (Rear Final Drive 0D2, 0D3, 0DB, 0B0, 0BX, 0DG, 0G2, 09R) (Coupe))

• 39 Final Drive, Differential
  • Safety Precautions
  • Driveshaft
    • Overview - Driveshaft
      • Notes
      • Driveshaft with outer axial support
    • Driveshaft, Removing And Installing
      • Driveshaft, Removing And Installing, AUDI A4, A5 And Q5
      • Drive Shaft, Removing From Rear Final Drive And Installing
    • Boot, Replacing
  • Final Drive
    • Overview - Final Drive
      • Overview - Rear Final Drive, AUDI A4 And A5
    • Final Drive, Removing And Installing
      • Rear Final Drive, Removing And Installing, AUDI A4, A5
        • Notes
        • Final Drive, Removing:
        • Final Drive, Installing:
      • Rear Final Drive, Removing And Installing, AUDI A5
      • ADDITIONAL WORK AFTER REPLACING FINAL DRIVE 0D3 "quattro sport" AND 0BX "quattro sport"
    • Final Drive, Disassembling And Assembling
      • Notes
      • OVERVIEW - FINAL DRIVE, DISASSEMBLING AND ASSEMBLING, 0B0 "quattro ultra", 09R "quattro ultra"
      • OVERVIEW - HOUSING, 0B0 "quattro ultra"
      • OVERVIEW - REAR ALL-WHEEL DRIVE CLUTCH, 0B0 "quattro ultra"
      • OVERVIEW - FINAL DRIVE, DISASSEMBLING AND ASSEMBLING, 0D3 AND 0BX "quattro sport"
      • Driveshaft Speed Sensor -G970-, REMOVING AND INSTALLING, 0B0 "quattro ultra", 09R "quattro ultra"
        • Removing
        • Installing
      • All-Wheel Drive Clutch Actuator 2 -V623-, REMOVING AND INSTALLING, 0B0 "quattro ultra", 09R "quattro ultra"
      • REPLACE SHIFT FORK, 0B0 "quattro ultra"
      • HYDRAULIC CONTROL UNIT, REMOVING AND INSTALLING, 0D3 "quattro sport" AND 0BX "quattro sport"
        • Notes
        • Removing
        • Installing
        • Attach the hydraulic control unit to the rear final drive as follows:
    • HYDRAULIC CONTROL UNIT, 0D3 "quattro sport" AND 0BX "quattro sport"
      • Overview - Hydraulic Control Unit 0D3 And 0BX
      • All-Wheel Drive Pump -V415-, REMOVING AND INSTALLING, 0D3 AND 0BX
        • Notes
        • Install the All-Wheel Drive Pump -V415-
      • Oil Pressure/Temperature Sensor -G437- OR Oil Pressure/Temperature Sensor 2 -G640-, REMOVING AND INSTALLING, 0D3 AND 0BX
        • Notes
        • Removing
        • Installing
      • All-Wheel Drive Clutch Valve -N445- OR All-Wheel Drive Clutch Valve 2 -N446-, REMOVING AND INSTALLING, 0BE AND 0BX
        • Notes
        • Removing
        • Installing
    • TORQUE DISPLACEMENT, CHECKING, 0D3 "quattro sport" AND 0BX "quattro sport"
  • Gear Oil
    • Component Location Overview - Drain And Check Plugs
      • Component Location Overview - Drain And Check Plugs, 0DB, 0D2 And 0G1 / 0G2
      • COMPONENT LOCATION OVERVIEW - DRAIN AND CHECK PLUGS, 0B0 "quattro ultra"
      • COMPONENT LOCATION OVERVIEW - DRAIN AND CHECK PLUGS, 09R "quattro ultra"
      • COMPONENT LOCATION OVERVIEW - DRAIN AND CHECK PLUGS, 0D3 "quattro sport" AND 0BX "quattro sport"
    • Gear Oil, Checking Level
      • Gear Oil Level, Checking, 0DB, 0D2 And 0G1 / 0G2
      • GEAR OIL LEVEL, CHECKING, 0B0 "quattro ultra"
      • GEAR OIL LEVEL, CHECKING, 09R "quattro ultra"
      • GEAR OIL LEVEL, CHECKING, 0D3 "quattro sport" AND 0BX "quattro sport"
    • Gear Oil, Draining And Filling
      • Gear Oil, Draining And Filling, 0DB, 0D2, 0G2, 0DG
      • GEAR OIL, DRAINING AND FILLING, 0B0, 09R "quattro ultra"
      • GEAR OIL, DRAINING, 0D3 "quattro sport" AND 0BX "quattro sport"
      • GEAR OIL, FILLING, 0D3 "quattro sport"
  • ATF
    • ATF Level, Checking
      • ATF LEVEL, CHECKING, 0D3 "quattro sport" AND 0BX "quattro sport"
    • ATF, Draining And Filling
      • ATF, DRAINING, 0D3 "quattro sport"
      • ATF, FILLING, 0D3 AND 0BX "quattro sport"
  • Seals
    • Component Location Overview - Seals
      • Component Location Overview - Seals, 0DB, 0D2 And 0G1 / 0G2
      • COMPONENT LOCATION OVERVIEW - SEALS, 0B0 "quattro ultra"
      • COMPONENT LOCATION OVERVIEW - SEALS, 09R "quattro ultra"
      • COMPONENT LOCATION OVERVIEW - SEALS, 0D3 "quattro sport" AND 0BX "quattro sport"
      • COMPONENT LOCATION OVERVIEW - SEALS ON ALL-WHEEL DRIVE CLUTCH "quattro ultra"
    • Left Seal, Replacing
      • LEFT SEAL, REPLACING, 0DB, 0D2, 0G2, 0DG, 0B0 "quattro ultra", 09R "quattro ultra"
      • LEFT SEAL, REPLACING, 0D3 "quattro sport" AND 0BX "quattro sport"
        • Notes
        • Removing
        • Installing
    • Right Seal, Replacing
      • Right Seal, Replacing, Final Drive 0DB, 0D2, 0DG And 0G2
      • RIGHT SEAL, REPLACING, FINAL DRIVE 0B0 "quattro ultra"
      • RIGHT SEAL, REPLACING, FINAL DRIVE 09R "quattro ultra"
      • RIGHT SEAL, REPLACING, 0D3 AND 0BX "quattro sport"
    • Input Shaft Seal, Replacing
      • INPUT SHAFT SEAL, REPLACING, 0DB, 0D2, 0G2, 09R "quattro ultra", 0B0 "quattro ultra"
        • Notes
        • Removing
        • Installing
      • INPUT SHAFT SEAL, REPLACING, 0D3 "quattro sport"
        • Notes
        • Removing
        • Installing
        • Install the circlip as follows:
    • Flange Shaft Protective Ring, Replacing
      • Flange Shaft Protective Ring, Replacing, 0DB, 0D2 And 0G1 / 0G2
      • PROTECTIVE RING ON FLANGE SHAFT, REPLACING, 0D3 AND 0BX "quattro sport"
      • FLANGE SHAFT PROTECTIVE RING, REPLACING, 0B0 AND 09R "quattro ultra"
    • Flange/Driveshaft Protective Ring, Replacing
  • Assembly Mounts
    • Bonded Rubber Bushing, Removing And Installing
  • All-Wheel Drive Clutch
    • Overview - All-Wheel Drive Clutch
    • Component Location Overview - Drain And Check Plugs
    • All-Wheel Drive Clutch, Removing And Installing
      • Notes
      • Removing
      • Installing
    • Additional Work When Replacing All-Wheel Drive Clutch
    • Oil Level, Checking
    • All-Wheel Drive Clutch Oil, Draining And Filling
      • Notes
      • Install
    • Control Module, Removing And Installing
      • Notes
      • Removing
      • Installing
    • ADDITIONAL WORK FOR VEHICLES WITH "quattro ultra"
    • All-Wheel Drive Clutch Torque, Checking
    • All-Wheel Drive Clutch Output Shaft Seal, Replacing
      • Notes
      • Removing
      • Installing
    • All-Wheel Drive Clutch Input Shaft Seal, Replacing
      • Notes
      • Removing
      • Installing
  • Transmission Control
    • Component Location Overview - Transmission Control
      • Component Location Overview - Transmission Control, AUDI A4 And A5
    • All-Wheel Drive Control Module -J492-, REMOVING AND INSTALLING, VEHICLES WITH "quattro ultra"
    • Differential Lock Control Module -J187-, REMOVING AND INSTALLING, VEHICLES WITH "quattro sport"
      • Differential Lock Control Module -J187-, REMOVING AND INSTALLING, AUDI A4 AND A5 WITH "quattro sport"
    • ADDITIONAL WORK AFTER REPLACING Differential Lock Control Module -J187-