LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2008 >> FJ Cruiser RWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 194 (Supplemental Restraint System) >> CURTAIN SHIELD AIRBAG ASSEMBLY (for Sedan) >> Removal

CURTAIN SHIELD AIRBAG ASSEMBLY (for Sedan): Removal

WARNING: This page is about a different car, the 2008 Toyota Yaris. However, it is still accessible from the selected car via links, so may be relevant.
CAUTION: Some of these service operations affect the SRS airbag system. Read the precautionary notices concerning the SRS airbag system before servicing (See AIRBAG SYSTEM  ).

HINT:

The procedure described below is for the RH side. Use the same procedure for both the RH and LH sides, unless otherwise specified.

  1. DISCONNECT BATTERY NEGATIVE TERMINAL 
  2. REMOVE FRONT SEAT HEADREST ASSEMBLY  (See REMOVAL )
  3. REMOVE FRONT SEAT ASSEMBLY LH  REMOVAL 
  4. REMOVE FRONT SEAT ASSEMBLY RH  (See REMOVAL )
  5. REMOVE REAR SEAT CUSHION COVER PAD SUB-ASSEMBLY  (See REMOVAL )
  6. REMOVE REAR SEATBACK ASSEMBLY (for Fixed Seat Type)  REMOVAL 
  7. REMOVE REAR SEATBACK ASSEMBLY LH (for 60/ 40 Split Seat Type)  (See REMOVAL )
  8. REMOVE REAR SEATBACK ASSEMBLY RH (for 60/ 40 Split Seat Type)  (See REMOVAL )
  9. REMOVE LUGGAGE COMPARTMENT FLOOR MAT (for 60/40 Split Seat Type)  (See DISASSEMBLY )
  10. REMOVE SPARE WHEEL COVER ASSEMBLY (for 60/ 40 Split Seat Type)  (See DISASSEMBLY )
  11. REMOVE LUGGAGE COMPARTMENT TRIM INNER PAD (for 60/40 Split Seat Type)  (See DISASSEMBLY )
  12. REMOVE FRONT DOOR SCUFF PLATE RH  (See REMOVAL )
  13. REMOVE FRONT DOOR SCUFF PLATE LH  (See REMOVAL )
  14. REMOVE INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY RH  (See REMOVAL )
  15. REMOVE INSTRUMENT PANEL UNDER COVER SUB-ASSEMBLY LH  (See REMOVAL )
  16. REMOVE COWL SIDE TRIM BOARD RH  (See REMOVAL )
  17. REMOVE COWL SIDE TRIM BOARD LH  (See REMOVAL )
  18. REMOVE FRONT DOOR OPENING TRIM WEATHERSTRIP RH  (See REMOVAL )
  19. REMOVE FRONT DOOR OPENING TRIM WEATHERSTRIP LH  (See REMOVAL )
  20. REMOVE REAR DOOR SCUFF PLATE RH  (See REMOVAL )
  21. REMOVE REAR DOOR SCUFF PLATE LH  (See REMOVAL )
  22. REMOVE REAR DOOR OPENING TRIM WEATHERSTRIP RH  (See REMOVAL )
  23. REMOVE REAR DOOR OPENING TRIM WEATHERSTRIP LH  (See REMOVAL )
  24. REMOVE REAR SEAT SIDE COVER RH  (See REMOVAL )
  25. REMOVE REAR SEAT SIDE COVER LH  (See REMOVAL )
  26. REMOVE ROOF SIDE INNER GARNISH RH  (See REMOVAL )
  27. REMOVE ROOF SIDE INNER GARNISH LH  (See REMOVAL )
  28. REMOVE CENTER PILLAR LOWER GARNISH RH  (See REMOVAL )
  29. REMOVE CENTER PILLAR LOWER GARNISH LH  (See REMOVAL )
  30. REMOVE SEAT BELT ANCHOR COVER CAP  (See REMOVAL )
  31. REMOVE FRONT SEAT OUTER BELT ASSEMBLY RH  (See REMOVAL )
  32. REMOVE FRONT SEAT OUTER BELT ASSEMBLY LH  (See REMOVAL )
  33. REMOVE CENTER PILLAR UPPER GARNISH RH  (See REMOVAL )
  34. REMOVE CENTER PILLAR UPPER GARNISH LH  (See REMOVAL )
  35. REMOVE FRONT PILLAR GARNISH RH  (See REMOVAL )
  36. REMOVE FRONT PILLAR GARNISH LH  (See REMOVAL )
  37. REMOVE INSTRUMENT PANEL LOWER CENTER FINISH PANEL  (See REMOVAL )
  38. REMOVE SHIFT LEVER KNOB SUB-ASSEMBLY (for Manual Transaxle)  (See REMOVAL )
  39. REMOVE REAR CONSOLE BOX UPPER FRONT PANEL SUB-ASSEMBLY  (See REMOVAL )
  40. REMOVE REAR CONSOLE BOX UPPER REAR PANEL SUB-ASSEMBLY  (See REMOVAL )
  41. REMOVE REAR CONSOLE BOX CARPET  (See REMOVAL )
  42. REMOVE REAR CONSOLE BOX ASSEMBLY  (See REMOVAL )
  43. REMOVE INSTRUMENT PANEL FINISH PANEL END RH  (See REMOVAL )
  44. REMOVE INSTRUMENT PANEL FINISH PANEL END LH  (See REMOVAL )
  45. REMOVE INSTRUMENT CLUSTER FINISH PANEL  (See REMOVAL )
  46. REMOVE COMBINATION METER ASSEMBLY  (See REMOVAL )
  47. REMOVE GLOVE COMPARTMENT DOOR ASSEMBLY  (See REMOVAL )
  48. REMOVE UPPER INSTRUMENT PANEL SUB-ASSEMBLY  (See REMOVAL )
  49. REMOVE INSTRUMENT PANEL BOX  (See REMOVAL )
  50. REMOVE ASSIST GRIP COVER  (See REMOVAL )
  51. REMOVE ASSIST GRIP SUB-ASSEMBLY  (See REMOVAL )
  52. REMOVE VISOR ASSEMBLY RH  (See REMOVAL )
  53. REMOVE VISOR ASSEMBLY LH  (See REMOVAL )
  54. REMOVE VISOR HOLDER RH  (See REMOVAL )
  55. REMOVE VISOR HOLDER LH  (See REMOVAL )
  56. REMOVE ROOM LIGHT ASSEMBLY  (See REMOVAL )
  57. REMOVE MAP LIGHT ASSEMBLY  (See REMOVAL )
  58. REMOVE ROOF HEADLINING ASSEMBLY  (See REMOVAL )
  59. REMOVE CURTAIN SHIELD AIRBAG ASSEMBLY RH 
    1. Using a thin-bladed screwdriver, release the locking button.
    2. Using a thin-bladed screwdriver, detach the airbag connector.
    3. Remove the 9 bolts, disengage the 3 hooks and remove the curtain shield airbag.
      Fig 1: Removing Locking Button
      G04830316Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Fig 2: Locating Curtain Shield Airbag And Bolts With Hooks
      G04830317Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  60. REMOVE CURTAIN SHIELD AIRBAG BRACKET RH 
    1. Remove the bolt, disengage the 2 hooks and remove the curtain shield airbag bracket.
      Fig 3: Locating Curtain Shield Airbag Bracket
      G04830318Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  61. REMOVE ROOF SIDE RAIL BRACKET RH 
    1. Remove the 2 bolts, disengage the 2 hooks and remove the roof side rail bracket.
scientia non olet · About LEMON Manuals