Section 1070 (Rear Axle - Repair - E90/E91)
WARNING: This page does not describe the selected car, but rather 9 other vehicles, including the 2008 BMW 335i, 2008 BMW 328i, 2008 BMW 323i, 2007 BMW 335i, and 2007 BMW 328i. However, it is still accessible from the selected car via links, so may be relevant.
- 00 General
- 00 Danger of poisoning if oil is ingested/absorbed through the skin
- 00 Risk of injury if oil comes into contact with eyes and skin
- 00 Safety instructions for handling oil
- 00 ... ... Raising vehicle with trolley jack
- 33 .. . Rear axle layout
- 33 00 ... Information on replacing shock absorbers
- 33 00 ... Instructions (chassis components made of aluminium)
- 33 00 ... Notes on repairing threads
- 33 00 ... Rear axle: wheel/chassis alignment check must be carried out after the following work
- 33 31 ... Overview of rear axle carrier with rubber mounts
- 33 32 ... Overview of steering links
- 10 Final drive
- 11 Final drive with cover
- 00 11 ... Checking/topping up oil level in rear differential
- 00 11 259 Oil change in rear differential incl. used oil disposal
- 33 11 ... Replacing rear cover gasket on rear differential (168L)
- 33 11 ... Replacing rear cover gasket on rear differential (188L / 188LW)
- 33 11 ... Replacing rear cover gasket on rear differential (215L / 215LW)
- 33 11 021 Replacing shaft seal for input flange on final drive
- 33 11 091 Replacing drive flange on left or right of rear differential
- 33 11 151 Replacing shaft seal for drive flange left or right
- 33 11 271 Replacing rear cover gasket on rear differential
- 17 Final drive mounting
- 21 Output shafts
- 33 21 ... Pressing output shaft out of drive flange and drawing in (output shaft removed from rear differential)
- 33 21 ... Ribbed teeth
- 33 21 001 Removing and installing or replacing left output shaft
- 33 21 002 Removing and installing / replacing right output shaft
- 33 21 035 Replacing gaiter on left output shaft (altered sealing cover)
- 33 21 036 Replacing gaiter on right output shaft
- 31 Rear sub-frame
- 32 Control arms and struts
- 33 32 021 Replacing left or right trailing arm
- 33 32 031 Replacing rubber mount for trailing arm in wheel carrier
- 33 32 035 Replacing a rubber mount for trailing arm in rear axle carrier
- 33 32 071 Replacing one upper control arm
- 33 32 091 Replacing a guide arm
- 33 32 125 Replacing a ball joint in lower steering knuckle/wheel carrier
- 33 32 131 Removing and installing / replacing a steering knuckle / wheel carrier
- 33 32 180 Removing and installing/replacing left or right toe arm
- 33 32 190 Removing and installing/replacing left or right camber arm
- 33 32 195 Replacing rubber mount for camber arm in rear axle carrier
- 51 75 001 Removing and installing/replacing left or right underbody cover
- 33 Axle mounting
- 41 Wheel bearings
- 33 41 005 Replacing left drive flange on rear axle shaft
- 33 41 007 Replacing right drive flange on rear axle shaft
- 33 41 153 Replacing wheel bearing (75 mm) on rear axle shaft on left
- 33 41 153 Replacing wheel bearing (85 mm) on rear axle shaft on left
- 33 41 155 Replacing right wheel bearing on rear axle shaft
- 52 Shock absorber
- 33 00 ... Information on replacing shock absorbers
- 33 52 000 Removing and installing / replacing rear left or right shock absorber
- 33 52 031 Replacing rear left or right rubber mount for shock absorber mounting
- 33 52 161 Replacing thrust bearing (lower section) for rear left or right spring strut/shock absorber
- 53 Springs with suspension
- 55 Stabilizer bar
- 90 Troubleshooting