Section 577 (Rear Drive Axle/Differential-DANA 60 & 70)
WARNING: This page is about a different car, the 2004 Ford RV Cutaway, 2004 Ford Econoline, 2004 Ford E450 Super Duty, and 2004 Ford Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Description And Operation
- Diagnosis And Testing
- Rear Drive Axle and Differential
- Notes
- Inspection and Verification
- Diagnostic Routines
- Diagnostic Routine - Fluid Loss
- Diagnostic Routine - Noise Louder on Turns (Sweeping)
- Diagnostic Routine - Noise (Growl) In Tight Turn, Conventional Differential
- Diagnostic Routine - Noise (Chatter/Shudder) In Tight Turns, Limited Slip Differential
- Diagnostic Routine - Noise (Whine) In All Or More Than One Drive Modes
- Diagnostic Routine - Noise (Tick/Click) In All Or More Than One Drive Modes
- Diagnostic Routine - Noise (Howl/Moan) In All Or More Than One Drive Modes
- Diagnostic Routine - Noise (Clunk) On Changes In Speed Or Direction Of Power
- Checking Differential Ring Gear Backlash
- Checking Tooth Contact Pattern and Condition of the Ring and Pinion
- Rear Drive Axle and Differential
- General Procedures
- In-Vehicle Repair
- Axle Shaft - Semi-Floating Axle
- Rear Wheel Bearing and Axle Shaft Oil Seal - Semi-Floating Axle
- Drive Pinion Flange and Drive Pinion Seal
- Differential Housing Cover
- Differential Ring and Pinion - Dana 60
- Differential Bearings - Dana 60
- Differential Ring and Pinion -Dana 70
- Differential Bearings -Dana 70
- Axle Housing
- Differential Carrier -Dana 60
- Removal And Installation
- Disassembly And Assembly