Steering And Wheel Alignment - Repair (F30, 6-CYL RWD)

• 32 00 Steering, General Information
  • 32 00... Additional work for camber correction
  • 32 00... General chassis and suspension definitions
  • 32 00... General information and definitions
  • 32 00... Identification of suspension without label
  • 3200 Instructions and specifications for replacement of steering gear/steering column/steering shaft following accident damage
  • 3200 KDS data statuses
  • 32 00... Moving vehicle into design position
  • 32 00... Moving vehicle into normal position
  • 3200 Test conditions for chassis/wheel alignment check
  • (5147-01 Removing the front underbody protection)
  • 32 00 150 Carry out Kinematics Diagnosis System wheel alignment with vehicle load up to design position
  • 32 00 155 Kinematics Diagnosis System wheel alignment with ride height measurement without loading the vehicle
  • 32 00 601 Adjusting toe-in on front axle
  • 32 00 620 Adjusting rear axle
• 32 11 Steering Box
  • 32 11... Notes on checking steering backlash on vehicles with rack-and-pinion steering
  • 32 11 100 Replacing gaiter for steering box on left or right
• 32 13 Electric Steering Gear / Servo
  • 32 13 572 Replace electrical steering box (EPS)
  • 32 13 572 Replacing the electric steering gear (EPS) (without wheel alignment)
    • Notes
    • REP-TAT-P-3213-01-F30 Remove the electromechanical steering gear
    • REP-TAT-P-3221-26 Remounting the track rod end on left and right
    • REP-TAT-P-3213-02-F30 Install the electromechanical steering gear
  • 32 13 580 Replacing the EPS steering thrust piece (ThyssenKrupp)
• 32 21 Tie Rod
  • 32 21 151 Replacing left or right track rod end
  • 32 21 151 Replacing left or right track rod end (without wheel alignment)
    • Notes
    • REP-TAT-P-3221-01-F30 Removing the track rod end
    • REP-TAT-P-3221-26 Remounting the track rod end
    • REP-TAT-P-3221-02 Installing track rod end
  • 32 21 231 Replacing (removing and installing) left or right track rod
• 32 31 Steering Column
  • 32 31 004 Removing and installing/replacing steering column shroud upper section
    • REP-TAT-P-3231-01 Removing steering column shroud upper section
    • REP-TAT-P-3231-02 Fit steering column shroud upper section
  • 32 31 020 Removing and installing/replacing steering column shroud lower section
    • Notes
    • REP-TAT-P-3231-01 Removing steering column shroud lower section
    • REP-TAT-P-3231-02 Install steering column shroud lower section
  • 32 31 070 Removing and installing/replacing lower section of steering shaft
  • 32 31 090 Removing and installing/replacing steering column
  • 32 31 102 Replacing steering shaft collar
  • 32 31 241 Replacing adjusting lever for steering column
• 32 33 Steering Wheel
  • 32 33 000 Removing and installing/replacing steering wheel
  • 32 33 010 Removing and installing/replacing sport steering wheel
  • 32 33... Replacing design cover for sports steering wheel
  • 32 33 010 Removing and installing (replacing) M sports steering wheel
  • 32 33 016 Replacing design cover for M sports steering wheel
• 32 34 Driver's Airbag
  • 32 34 020 Removing and installing/replacing driver's airbag unit
  • 32 34 030 Removing and installing/replacing airbag unit (M sports steering wheel)
  • 32 34 030 Removing and installing/replacing airbag unit (sport steering wheel)
• 32 41 Ear Clips
  • 32 41... Instructions for removing and installing ear clips