Overview - Sliding Sunroof, A5: Notes

WARNING: This page is about a different variant/trim than selected.

Overview - Adhesive Bead on Sliding Sunroof. Refer to OVERVIEW - ADHESIVE BEAD ON SLIDING SUNROOF .
Overview - Sliding and Tilting Mechanism. Refer to Overview - Sliding and Tilting Mechanism .

Fig 1: Exploded View Of Sliding Sunroof, A5

Courtesy of AUDI OF AMERICA, LLC

Bolt
- Quantity: 3
- 4 Nm
Sunroof Motor -V1-
- Removing and Installing. Refer to Sunroof Motor -V1-, REMOVING AND INSTALLING, A5 .
- Perform the adaptation after installing. Refer to Sunroof Motor -V1-, PROGRAMMING .
Sunroof Control Module -J245-
- Removing and Installing. Refer to Sunroof Control Module -J245-, REMOVING AND INSTALLING, A5 .
Sunroof Frame
- Replace after removing
- Drain pipe, removing and installing. Refer to DRAIN PIPE, REMOVING AND INSTALLING .
- Removing and Installing:
  - Coupe. Refer to SUNROOF FRAME, REMOVING AND INSTALLING, A5 COUPE .
  - Sportback. Refer to SUNROOF FRAME, REMOVING AND INSTALLING, A5 SPORTBACK .
- Perform the adaptation after installing. Refer to Sunroof Motor -V1-, PROGRAMMING .
Seal
- Outside
- Bonded to the sunroof frame
- Replace after removing
- Removing and Installing. Refer to Outer Sunroof Seals, Removing and Installing: .
- Perform the adaptation after installing. Refer to Sunroof Motor -V1-, PROGRAMMING .
Seal
- Inner
- Bonded to the sunroof frame
- Replace after removing
- Removing and Installing. Refer to Self-adhesive sunroof seals, removing and installing: .
- Perform the adaptation after installing. Refer to Sunroof Motor -V1-, PROGRAMMING .
Glass Trim
- Replace after removing
- Removing and Installing. Refer to GLASS TRIM, REMOVING AND INSTALLING .
- Perform the adaptation after installing. Refer to Sunroof Motor -V1-, PROGRAMMING .
Glass Panel
- Removing and Installing. Refer to GLASS PANEL, REMOVING AND INSTALLING, A5 .
- Adjusting. Refer to GLASS PANEL, ADJUSTING, A5 .
- Perform the adaptation after installing. Refer to Sunroof Motor -V1-, PROGRAMMING .
- Emergency Opening. Refer to EMERGENCY OPENING .
Seal
- For the rear glass panel
- Replace after removing
- Removing and Installing. Refer to Self-adhesive sunroof seals, removing and installing: .
- Perform the adaptation after installing. Refer to Sunroof Motor -V1-, PROGRAMMING .
Seal
- For the side glass panel
- Replace after removing
- Removing and Installing. Refer to Self-adhesive sunroof seals, removing and installing: .
Rubber Trim
- Removing and Installing. Refer to RUBBER TRIM, REMOVING AND INSTALLING, A5 .
Bolt
- 3 Nm
Bolt
- Replace after removing
- Quantity: 6
- 5.5 Nm
Bolt
- Quantity: 3
- 4.5 Nm
Slide and Tilting Mechanism
- Removing and Installing. Refer to SLIDING AND TILTING MECHANISM, REMOVING AND INSTALLING .
- Overview - Sliding and Tilting Mechanism. Refer to Overview - Sliding and Tilting Mechanism .
- Perform the adaptation after installing. Refer to Sunroof Motor -V1-, PROGRAMMING .
Bolt
- 4.5 Nm
Side Trim
- Removing and Installing. Refer to SIDE TRIM, REMOVING AND INSTALLING .
Guide
- For the slide and tilting mechanism
- Removing and Installing. Refer to SLIDING AND TILTING MECHANISM GUIDE, REMOVING AND INSTALLING .
Bolt
- Quantity: 3
- 8 Nm
- Tightening Sequence:
  - Coupe. Refer to Installing .
  - Sportback. Refer to Installing .