Section 55 (Parking Brake - Removal, Replacement And Installation)
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.
- Brake Controls, Mechanical (1999-2006)
- Handle, parking brake lever, replacing
- Replacing brake cables
- Removal
- Remove the mechanical cable from its segment
- Secure a heavy wire to the end of the mechanical cable
- Remove the mechanical cable
- Remove the brake caliper with the holder and the brake disc
- Remove the expander
- Remove the guide sleeve for the cable sleeve
- Remove the mechanical brake cable
- Installation
- Install the cable in the wheel unit
- Install the expander on the mechanical cable
- Install the brake cable in its clamps
- Pull the cable up to the brake lever
- Install the rubber seal against the bodywork
- Install the cable to the parking brake segment
- Install the center console
- Install the brake disc and the brake caliper with the holder
- Replacing the parking brake lever
- Brakes (1999-2006)