LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2008 >> FJ Cruiser RWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 218 (Seat Belt) >> REAR CENTER SEAT OUTER BELT ASSEMBLY (for Hatchback 3 Door) >> Removal

REAR CENTER SEAT OUTER BELT ASSEMBLY (for Hatchback 3 Door): Removal

WARNING: This page is about a different car, the 2008 Toyota Yaris. However, it is still accessible from the selected car via links, so may be relevant.
NOTE: Always use "Torx" socket wrench E10 when removing the rear seat.
  1. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL 
  2. REMOVE PACKAGE TRAY TRIM PANEL ASSEMBLY  (See REMOVAL )
  3. REMOVE DECK BOARD SUB-ASSEMBLY  (See REMOVAL )
  4. REMOVE DECK FLOOR BOX RH  (See REMOVAL )
  5. REMOVE DECK FLOOR BOX LH  (See REMOVAL )
  6. REMOVE NO. 1 REAR SEAT LEG COVER (for 60/40 Split Seat Type) 
    1. for RH Side:
      1. Remove the No. 1 rear seat leg cover (See REMOVAL ).
    2. for LH Side:
      1. Remove the No. 1 rear seat leg cover (See REMOVAL ).
  7. REMOVE NO. 2 REAR SEAT LEG COVER (for 60/40 Split Seat Type)  (See REMOVAL )
  8. REMOVE REAR SEAT ASSEMBLY RH (for 60/40 Split Seat Type)  (See REMOVAL )
  9. REMOVE REAR SEAT ASSEMBLY LH (for 60/40 Split Seat Type)  (See REMOVAL )
  10. REMOVE REAR SEAT CUSHION COVER PAD SUB-ASSEMBLY (for Hold Down Seat Type)  (See REMOVAL )
  11. REMOVE REAR SEATBACK ASSEMBLY (for Hold Down Seat Type)  REMOVAL 
  12. REMOVE FRONT DOOR SCUFF PLATE RH  (See REMOVAL )
  13. REMOVE FRONT DOOR SCUFF PLATE LH  (See REMOVAL )
  14. REMOVE FRONT DOOR OPENING TRIM WEATHERSTRIP RH (See REMOVAL  )
  15. REMOVE FRONT DOOR OPENING TRIM WEATHERSTRIP LH 

    HINT:

    Use the same procedure as for the RH side.

  16. REMOVE FRONT QUARTER TRIM PANEL ASSEMBLY RH  (See REMOVAL )
  17. REMOVE FRONT QUARTER TRIM PANEL ASSEMBLY LH  (See REMOVAL )
  18. REMOVE REAR DECK TRIM COVER  (See REMOVAL )
  19. REMOVE REAR SEAT OUTER BELT ASSEMBLY RH  (See REMOVAL )
  20. REMOVE REAR SEAT OUTER BELT ASSEMBLY LH  (See REMOVAL )
  21. REMOVE DECK TRIM SIDE PANEL ASSEMBLY RH  (See REMOVAL )
  22. REMOVE DECK TRIM SIDE PANEL ASSEMBLY LH  (See REMOVAL )
  23. REMOVE ROOF SIDE INNER GARNISH RH 
    1. Using a screwdriver with its tip wrapped in protective tape, disengage the 4 claws and remove the center belt guide.
      Fig 1: Disengaging Claws
      G04835472Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. w/ Curtain shield Airbag:
      NOTE: Replace the special clip with a new one when the roof side inner garnish is removed.
      1. Disengage the 4 clips and the claw.
      2. Pass the rear seat outer belt and the rear center seat outer belt through the slit in the roof side inner garnish and remove the roof side inner garnish.
        Fig 2: Identifying Roof Side Inner Garnish RH Clips And Claws - W/O Curtain Shield Airbag
        G04835602Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    3. w/o Curtain Shield Airbag:
      1. Disengage the 4 clips and the claw.
      2. Pass the rear seat outer belt and the rear center seat outer belt through the slit in the roof side inner garnish and remove the roof side inner garnish.
  24. REMOVE ROOF SIDE INNER GARNISH LH  (See REMOVAL )
  25. REMOVE REAR CENTER SEAT OUTER BELT ASSEMBLY (See REMOVAL  )
  26. REMOVE SEAT BELT ANCHOR COVER (See REMOVAL  )
  27. REMOVE ROOF HEADLINING ASSEMBLY  (See REMOVAL  )
    Fig 3: Identifying Roof Side Inner Garnish LH Clips And Claws - W/ Curtain Shield Airbag
    G04835603Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  28. REMOVE REAR SEAT SHOULDER BELT COVER  (See REMOVAL  )
scientia non olet · About LEMON Manuals