LEMON Manuals: Even more car manuals for everyone
Home >> Subaru >> 2021 >> Crosstrek Hybrid >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 2 (HVAC System (Heater, Ventilator And A/C) (Except For HEV)) >> Evaporator >> Removal

Section 2 (HVAC System (Heater, Ventilator And A/C) (Except For HEV)): Evaporator: Removal

WARNING: This page is about a different variant/trim than selected.
CAUTION: Before handling the airbag system components, refer to "CAUTION" of "General Description" in "AIRBAG SYSTEM". Ref. to AIRBAG SYSTEM>GENERAL DESCRIPTION>CAUTION .
  1. Using the refrigerant recovery system, discharge refrigerant. Ref. to AIR CONDITIONER (EXCEPT FOR HEV)> REFRIGERANT RECOVERY PROCEDURE>PROCEDURE .
  2. Disconnect the ground terminal from the battery sensor, and wait for at least 60 seconds before starting work. Ref. to REPAIR CONTENTS>REPAIR CONTENTS>NOTE>BATTERY .
  3. Drain the coolant from the radiator. Ref. to COOLING (H4DO (EXCEPT FOR HEV))>ENGINE COOLANT>REPLACEMENT>DRAINING OF ENGINE COOLANT .
  4. Remove the heater and cooling unit assembly. Ref. to AIR CONDITIONER (EXCEPT FOR HEV)>HEATER AND COOLING UNIT>REMOVAL .
  5. Remove the heater core. Ref. to AIR CONDITIONER (EXCEPT FOR HEV)>HEATER CORE> REMOVAL .
  6. Remove the motor - actuator mix LH and RH. (Auto A/C model) Ref. to AIR CONDITIONER (EXCEPT FOR HEV)>AIR MIX DOOR ACTUATOR>REMOVAL .
  7. Remove the bracket - cable. (Manual A/C model)
    1. Remove the screws, and then remove the bracket - heater cable.
      G11245682Courtesy of SUBARU OF AMERICA, INC.
  8. Remove the cover - evaporator.
    1. Remove the packing.
      G11245683Courtesy of SUBARU OF AMERICA, INC.
    2. Remove the screws and lock to remove the cover - evaporator.
      G11245684Courtesy of SUBARU OF AMERICA, INC.
  9. Remove the case assembly - heater unit.
    1. Remove the screws.
    2. Remove the lock, and remove the case assembly - heater unit.
      G11245685Courtesy of SUBARU OF AMERICA, INC.
  10. Remove the evaporator assembly - cooling as shown in the figure.
    G11245686Courtesy of SUBARU OF AMERICA, INC.
  11. Remove the evaporator sensor. Ref. to AIR CONDITIONER (EXCEPT FOR HEV)>EVAPORATOR SENSOR> REMOVAL .
scientia non olet · About LEMON Manuals