General Electrical System - Repair -- Cooper (F54)
- 61 00 General Vehicle Electrical System, Test
- Diagnosis for Condition Based Service
- Encode/program control unit(s)
- Notes for disconnecting and connecting the vehicle battery
- Notes on handling optical fibers
- Notes on handling the high pressure cleaner
- Notes on handling wiring harnesses and cables
- Repairing airbag cables
- Safety instructions for handling vehicle battery
- Safety instructions on handling hybrid cars
- Encode/program control unit(s) (after vehicle test) (Cooper Clubman base)
- programing/encoding the control unit(s) including deletion of fault memory (after vehicle test) (Cooper Clubman S and JCW)
- 61 12 Auxiliary Cable
- 61 13 Plug Connection, Terminal
- Butt connector for repairing a plug connection
- Circular connector, 13-pin, system D2.5
- Circular connector, 7-pin, 8-pin, system D2.5
- Circular connector, 20-pin, system D2.5
- Circular plugs, 4-, 7-, 10- 12-, 25-pin, System D1.5/D2.5
- Connector housing, LCC contact (load current contact)
- Control unit plugs, 25-, 35-, 55-, 83-, 88-pin
- Crimping Micro Power Quadlock contacts (MPQ)
- Crimping annular contacts
- Crimping Micro Quadlock System contacts (MQS)
- Crimping optical fibers
- Cutting, strip off insulation and crimping optical fibers
- Cutting to length and stripping insulation from cables
- Handling cables and optical fibers
- Inline connectors, 15-pin, System D2.5
- In-line connectors, 24-/44-pin, Hybrid System MQS/MPQ
- In-line connectors, 30-pin, System D2.5
- In-line connectors, 30-pin, Hybrid System MQS/MPQ
- In-line plugs, 20-pin, System D2.5
- In-line plugs, 2-pin, System JPT ELA
- Inline connectors, 6-, 8-pin, System MQS
- In-line plugs, 2-pin, System MDK 3 plus 2.8
- Inline plugs, 2-pin, System MPQ 2.8
- Inline plugs, 3-, 6-pin, System Elo-Power 2.8
- In-line plugs, 4-pin, System DFK ELA
- Inline plugs, 4-, 10-pin, System Elo
- Inline plugs, 8-, 12-pin, System D2.5
- In-line plugs, 6- to 50-pin, System Elo
- Installing comb connector for retrofitting/repairs
- Notes for opening contacts and locks of different plug contact systems
- Opening plug housings and removing contacts of different plug systems
- Socket housing (radio connector), Hybrid System MQS/MPQ
- Socket housing 42-, 43-, 46-pin, Hybrid System MQS/MPQ
- Socket housings, 2x21-, 2x27-pin, Hybrid Systems MQS/MPQ, Elo/Elo Power
- Socket housings, 5-pin, 8-pin, System MQS/MPQ
- Special tools for wiring harness repairs
- Unlocking and disconnecting different plug connections
- Unlocking and disconnecting various plug connections in electrical and hybrid vehicles
- 61 14 Power Distribution, Power Connection Points
- 61 20 Battery
- 61 21 Battery With Holder
- 61 31 Switch, Sensor
- Removing and installing (replacing) the driving dynamics control
- Removing and installing (replacing) steering column switch cluster
- Replacing coil spring cassette
- Removing and installing/replacing Start/Stop switch
- Remove and install/replace ring antenna
- Removing and installing/replacing light control unit
- Remove and install roof switch center
- Removing and installing/replacing center console control panel
- Removing and installing/replacing switch for front passenger airbag deactivation
- Removing and installing/replacing switch for hazard warning flashers
- Removing and installing/replacing both shift paddles for automatic transmission
- Replacing the rocker switch for rear power electric windows
- Removing and installing/replacing power window switch (driver's side)
- Removing and installing/replacing USB audio interface connecting socket
- Removing and installing/replacing switch for electromechanical parking brake
- Removing and installing front controller
- Removing and installing/replacing both multifunction steering wheel switches
- Removing and installing (replacing) audio operating facility
- Removing and installing/replacing switch for assist system
- Replacing switch for vehicle exterior mirror
- Removing and installing/replacing clutch module
- Replacing brake light switch
- Removing and installing (replacing) receiver for radio remote control
- Replacing front controller
- 61 33 Horn
- 61 35 Control Units, Modules
- Notes on ESD protection (Electro Static Discharge)
- Overview, rain sensor (additional work when replacing the windshield/sensor replacement)
- Overview of additional work for the removal and installation or replacement of electronic components in the body area/windshield
- Removing and installing/replacing control unit/module for seat heating
- Removing and installing (replacing) rain/driving-light sensor
- Replacing and installing (replacing) the solar rain/driving-light sensor and condensation sensor
- Removing and installing (replacing) control unit for contactless trunk opening
- Removing and installing (replacing) the top sensor line for contactless trunk opening replace
- Removing and installing (replacing) the bottom sensor line for contactless trunk opening replace
- Remove/install Body Domain Controller (BDC)
- Removing and installing control unit for camera-based driver support systems (KAFAS)
- Replace Body Domain Controller control unit (BDC)
- Replacing control unit for camera-based driver support systems (KAFAS)
- Removing and installing/replacing the interior antenna for Comfort Access (front cup holder)
- Removing and installing/replacing interior antenna for Comfort Access (rear center console)
- Removing and installing/replacing luggage compartment antenna for Comfort Access
- Removing and installing/replacing bumper antenna for Comfort Access
- Removing and installing/replacing antenna for Comfort Access on left or right
- 61 61 Windshield Wiper
- 61 62 Rear Wiper
- 61 71 Windshield Washer System