Section 15 (Automatic Transmission - 6T45 (MHG) - Repair Instructions - Off Vehicle)
WARNING: This page is about a different variant/trim than selected.
- Repair Instructions - Off Vehicle
- Lift Plate and Holding Fixture Installation
- Torque Converter Removal
- Auxiliary Fluid Accumulator Removal (MHG)
- Control Valve Body Assembly Removal
- Input and Output Speed Sensor Removal
- Torque Converter Housing with Fluid Pump Assembly Removal
- Differential Carrier Removal
- Drive and Driven Sprocket, Drive Link, and Park Pawl Removal
- Internal Components Removal
- 2-6 Clutch Piston Removal
- Manual Shift Detent Lever with Shaft Position Switch Assembly and Park Pawl Actuator Removal
- Manual Shift Shaft Seal Removal
- Input Shaft Support Replacement
- 3-5-Reverse and 4-5-6 Clutch Fluid Seal Ring Replacement
- Front Wheel Drive Shaft Seal Replacement - Case Side
- Transmission Case Cleaning and Inspection
- Manual Shift Detent Lever with Shaft Position Switch Assembly and Park Pawl Actuator Installation
- Manual Shift Shaft Seal Installation
- 2-6 Clutch Piston Installation
- Low and Reverse and 1-2-3-4 Clutch Housing, Low and Reverse Clutch Assembly, Output Sun Gear, and 2-6 Clutch Plate Disassemble
- Input, Reaction, and Output Carrier Disassemble
- 3-5-Reverse and 4-5-6 Clutch Housing Disassemble
- 3-5-Reverse and 4-5-6 Clutch Housing Assemble
- Input, Reaction, and Output Carrier Assemble
- 3-5-Reverse and 4-5-6 Clutch Housing, and Input, Reaction, and Output Carrier Installation
- Low and Reverse Clutch Assembly and Low and Reverse Clutch Plate Installation
- Low and Reverse and 1-2-3-4 Clutch Housing Disassemble
- Low and Reverse and 1-2-3-4 Clutch Housing Cleaning and Inspection
- Low and Reverse and 1-2-3-4 Clutch Housing Assemble
- Low and Reverse and 1-2-3-4 Clutch Housing, and 1-2-3-4 Clutch Plate Installation
- Drive Sprocket, Driven Sprocket, and Drive Link Cleaning and Inspection
- Drive and Driven Sprocket, Drive Link, and Park Pawl Installation
- Front Differential Carrier Cleaning and Inspection
- Front Differential Carrier Installation
- Transmission Fluid Pump, Front Differential Carrier Baffle, and Front Differential Ring Gear Removal (Gen 3)
- Front Wheel Drive Shaft Seal Replacement - Torque Converter Housing Side
- Torque Converter Housing Cleaning and Inspection
- Transmission Fluid Pump Disassemble (Gen 3)
- Transmission Fluid Pump Assemble (Gen 3)
- Transmission Fluid Pump, Front Differential Carrier Baffle, and Front Differential Ring Gear Installation (Gen 3)
- Torque Converter Housing with Fluid Pump Assembly Installation
- Input and Output Speed Sensor Installation
- Control Valve Body Assembly Disassemble (Gen 3)
- Control Valve Body Cleaning and Inspection
- Control Valve Channel Plate Cleaning and Inspection
- Control Valve Body Assembly Assemble (Gen 3)
- Control Valve Body Assembly Installation
- Control Solenoid Valve and Transmission Control Module Assembly Installation
- Control Valve Body Cover Installation
- Auxiliary Fluid Accumulator Installation (MHG)
- Torque Converter Fluid Seal Replacement
- Torque Converter Installation
- Lift Plate and Holding Fixture Removal