63 12 140 Removing and installing (replacing) left headlight - LED technology -

WARNING: This page does not describe the selected car, but rather 18 other vehicles, including the 2017 BMW 550i GT xDrive, 2017 BMW 535i GT xDrive, 2017 BMW 535i GT, 2016 BMW 550i GT xDrive, and 2016 BMW 535i GT xDrive. However, it is still accessible from the selected car via links, so may be relevant.

WARNING: Follow notes for HANDLING BULBS/LIGHT SOURCES (EXTERIOR LIGHTS) !

Necessary preliminary tasks:

Remove FRONT BUMPER PANEL
Vehicles with auxiliary radiator:

Remove FRONT WHEEL ARCH COVER

Lever out expanding rivets (1) on engine compartment lid seal (2).

Fig 1: Identifying Expanding Rivets On Engine Compartment Lid Seal

G06886083

Courtesy of BMW OF NORTH AMERICA, INC.

Remove seal for engine compartment lid (2) on left.

Release screws (1) on headlight (3) at top.

Tightening torque 63 12 1AZ .

Fig 2: Identifying Engine Compartment Lid, Headlight, And Screws

G06886084

Courtesy of BMW OF NORTH AMERICA, INC.

Release screws (1) on headlight (2) at bottom.

Tightening torque 63 12 1AZ .

Fig 3: Identifying Bottom Headlight Screws

G06886085

Courtesy of BMW OF NORTH AMERICA, INC.

Pull out headlight (1) in direction of arrow slightly.

Fig 4: Pulling Out Headlight

G06886086

Courtesy of BMW OF NORTH AMERICA, INC.

Disconnect plug connection (1) on headlight (2) and remove headlight.

Fig 5: Identifying Plug Connection On Headlight

G06886087

Courtesy of BMW OF NORTH AMERICA, INC.

IMPORTANT: Follow instructions for HANDLING LIGHT BULBS (EXTERIOR LIGHTS) .

Replacement only:

Installation note:

Adjust HEADLIGHT .