Section 94 (Transmission Cable - Adjusting (644 Body))
WARNING: This page is about a different car, the 2004 Volvo S40, 2003 Volvo S40, 2002 Volvo S40, 2001 Volvo S40, and 2000 Volvo S40. However, it is still accessible from the selected car via links, so may be relevant.
- Adjusting Transmission Cable
- Transmission Removal, Oil, And Adaptation Of TCM
- Adaptation of Transmission Control Module (TCM)
- Changing oil, transmission
- Description of activations, transmission
- Gearbox, removing
- Notes
- Filling in Diagnostic and Check lists
- Disconnecting battery lead
- Removing engine compartment components
- Removing dipstick
- Removing gear selector cable from lever and mounting on gearbox
- Removing mounting screws from gearbox/starter motor
- Removing right screw from gearbox
- Installing lifting beam and lifting hook on engine lifting eyelet
- Removing splash guards
- Removing screws for cable conduit and ground lead bracket on sub-frame
- Removing nut for lower ball joint/control arm
- Remove control arms, track rod and spring strut on both sides
- Removing screws for sub-frame support plates (both sides)
- Removing stub axle from control arm
- Removing drive shaft from stub axle (right-hand side)
- Removing cap for drive shaft support bearing
- Removing drive shaft
- Press up sub-frame on right-hand side
- Removing nuts and screws for steering gear sub-frame
- Removing screws for torque rod from gearbox
- Removing exhaust pipe from turbocharger (TC)
- Removing front cross member
- Removing bracket for cable for heated oxygen sensor (HO2S) from sub-frame
- Removing exhaust pipe mounting in rear cross member
- Removing screw for rear engine pad
- Removing rear engine mounting
- Preparations for removing stub axle on left-hand side
- Removing left drive shaft from gearbox
- Lowering sub-frame
- Removing lower oil pipe from gearbox
- Lowering engine and gearbox
- Removing 6 screws for torque converter, and 7 screws for gearbox/engine
- Preparations when removing gearbox
- Installing fixture on mobile jack and gearbox
- Removing all 7 screws for gearbox/engine
- Removing gearbox
- Cleaning and checking
- Diagnostics/check list, transmission