Checks after replacing the transmission

WARNING: This page is about a different car, the 2002 Volvo C70, 2001 Volvo C70, 2000 Volvo C70, 1999 Volvo C70, and 1998 Volvo C70. However, it is still accessible from the selected car via links, so may be relevant.

Top up and check the engine coolant level before and during the test drive.

Fig 1: Locating Transmission Dipstick

Courtesy of VOLVO CARS OF NORTH AMERICA.

Check the oil level. See Oil level, checking .

NOTE:

If the transmission is replaced with a new or exchange transmission, it is supplied filled with oil plus a certain amount of "excess". This is to compensate for loss from the oil cooler. The oil level must always be checked however.

WARNING:

The lower engine coolant hose positioned by the dip stick is extremely hot. Use protective gloves when moving the hose to the side.

Test drive the car

Use the test driving schedule. See Test drive schedule, description .

NOTE:

Check that no diagnostic trouble codes (DTCs) have been stored during the test drive.

NOTE:

After replacing the transmission, the adaptation and the "Transmission oil change" counter must be reset. Use VIDA vehicle communication to set the adaptation and counters to zero.