LEMON Manuals: Even more car manuals for everyone
Home >> Volvo >> 2002 >> S60 Base, 2.4 61, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 72 (Rear Axle, Drive Shafts - Removal, Replacement And Installation) >> Drive Shaft, CV Joint (Ambulance; 2003-2004) >> Boot, half shaft, replacing >> Disassembly >> Only drive shafts with vibration damper:

Only drive shafts with vibration damper:

WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.
Fig 1: Identifying Shaft With Vibration Damper
GLL109819Courtesy of VOLVO CARS OF NORTH AMERICA.

Measure and note the vibration damper location on the shaft.

NOTE: When replacing the inner boot on a left drive shaft with the vibration damper installed (only applies to cars with automatic transmissions), the damper must be removed and installed. See Brush the drive shaft thoroughly with soapy water  and Position the shaft in a vice .
scientia non olet · About LEMON Manuals