LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2019 >> Prius Prime Plus >> Repair and Diagnosis >> Body & Frame >> Exterior Body Panels >> (Door / Hatch) (Service Information) (2 Of 2) >> Charge Lid Courtesy Switch >> Removal [07/2020 - ] >> Procedure

Removal [07/2020 - ]: Procedure

  1. PRECAUTION 
    WARNING:
    • Some of these service operations affect the SRS airbag system. Read the precautionary notices concerning the SRS airbag system before servicing.

      Refer to PRECAUTION [07/2020 - ]

    • Wait at least 90 seconds after disconnecting the cable from the negative (-) auxiliary battery terminal to disable the SRS system.
    GTY607029Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    NOTE:

    After turning the power switch off, waiting time may be required before disconnecting the cable from the negative (-) auxiliary battery terminal.

    Refer to PRECAUTION [05/2019 - ]

  2. DISCONNECT CABLE FROM NEGATIVE AUXILIARY BATTERY TERMINAL 

    Refer to PROCEDURE - Step 2

  3. REMOVE TONNEAU COVER ASSEMBLY 

    Refer to PROCEDURE - Step 3

  4. REMOVE REAR NO. 2 FLOOR BOARD 

    Refer to PROCEDURE - Step 4

  5. REMOVE REAR NO. 4 FLOOR BOARD 

    Refer to PROCEDURE - Step 5

  6. REMOVE REAR NO. 3 FLOOR BOARD 

    Refer to PROCEDURE - Step 6

  7. REMOVE REAR NO. 1 FLOOR BOARD 

    Refer to PROCEDURE - Step 7

  8. REMOVE DECK FLOOR BOX LH 

    Refer to PROCEDURE - Step 8

  9. REMOVE DECK FLOOR BOX RH 

    Refer to PROCEDURE - Step 9

  10. REMOVE DECK TRIM SERVICE HOLE COVER 

    Refer to PROCEDURE - Step 2

  11. REMOVE REAR DECK TRIM COVER 

    Refer to PROCEDURE - Step 11

  12. REMOVE REAR SEAT HEADREST ASSEMBLY 

    Refer to PROCEDURE - Step 1

  13. REMOVE REAR SEAT CENTER HEADREST ASSEMBLY 

    Refer to PROCEDURE - Step 3

  14. DISCONNECT REAR CENTER SEAT OUTER BELT ASSEMBLY 

    Refer to PROCEDURE - Step 4

  15. REMOVE REAR SEATBACK ASSEMBLY RH 

    Refer to PROCEDURE - Step 5

  16. REMOVE REAR SEAT CUSHION ASSEMBLY 

    Refer to PROCEDURE - Step 7

  17. REMOVE REAR SEAT CUSHION LOCK HOOK 

    Refer to PROCEDURE - Step 8

  18. REMOVE REAR DOOR SCUFF PLATE RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 16

  19. DISCONNECT REAR DOOR OPENING TRIM WEATHERSTRIP RH 
    1. Disconnect the rear door opening trim weatherstrip RH.
  20. REMOVE REAR UNDER SIDE COVER RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 33

  21. REMOVE REAR SEATBACK HINGE SUB-ASSEMBLY RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 34

  22. REMOVE REAR PILLAR COVER RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 35

  23. REMOVE REAR SEAT SIDE GARNISH RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 36

  24. REMOVE NO. 1 TONNEAU COVER HOLDER CAP 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 37

  25. REMOVE TONNEAU COVER HOOK A 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 38

  26. REMOVE NO. 1 LUGGAGE COMPARTMENT LIGHT ASSEMBLY 

    Refer to PROCEDURE - Step 1

  27. REMOVE DECK TRIM SIDE PANEL ASSEMBLY RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 39

  28. REMOVE NO. 1 HYBRID BATTERY INTAKE DUCT 

    Refer to PROCEDURE - Step 34

  29. REMOVE NO. 2 HYBRID BATTERY INTAKE DUCT 

    Refer to PROCEDURE - Step 35

  30. DISCONNECT AC CHARGER INLET CABLE (w/o CABLE EV CHARGER LOCK ASSEMBLY) 

    See step  30

  31. DISCONNECT AC CHARGER INLET CABLE WITH CABLE EV CHARGER LOCK ASSEMBLY (w/ CABLE EV CHARGER LOCK ASSEMBLY) 

    See step  31

  32. REMOVE FUEL FILLER OPENING LID LOCK BRACKET 

    See step  32

  33. REMOVE EV CHARGER LID SWITCH ASSEMBLY 
    1. Remove the 2 nuts and EV charger lid switch assembly.
      GTY696346Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals