LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2019 >> Prius Prime Plus >> Repair and Diagnosis >> Body & Frame >> Exterior Body Panels >> (Door / Hatch) (Service Information) (2 Of 2) >> Charge Lid Courtesy Switch >> Removal [05/2019 - 07/2020] >> Procedure

Removal [05/2019 - 07/2020]: Procedure

  1. REMOVE TONNEAU COVER ASSEMBLY 

    Refer to PROCEDURE - Step 1

  2. REMOVE REAR NO. 2 FLOOR BOARD 

    Refer to PROCEDURE - Step 2

  3. REMOVE REAR NO. 4 FLOOR BOARD 

    Refer to PROCEDURE - Step 3

  4. REMOVE REAR NO. 3 FLOOR BOARD 

    Refer to PROCEDURE - Step 4

  5. REMOVE REAR NO. 1 FLOOR BOARD 

    Refer to PROCEDURE - Step 5

  6. REMOVE DECK FLOOR BOX LH 

    Refer to PROCEDURE - Step 6

  7. REMOVE DECK FLOOR BOX RH 

    Refer to PROCEDURE - Step 7

  8. REMOVE DECK TRIM SERVICE HOLE COVER 

    Refer to PROCEDURE - Step 2

  9. REMOVE REAR DECK TRIM COVER 

    Refer to PROCEDURE - Step 9

  10. REMOVE REAR SEAT HEADREST ASSEMBLY 

    Refer to PROCEDURE - Step 1

  11. REMOVE REAR SEAT CENTER HEADREST ASSEMBLY 

    Refer to PROCEDURE - Step 3

  12. DISCONNECT REAR CENTER SEAT OUTER BELT ASSEMBLY 

    Refer to PROCEDURE - Step 4

  13. REMOVE REAR SEATBACK ASSEMBLY RH 

    Refer to PROCEDURE - Step 5

  14. REMOVE REAR SEAT CUSHION ASSEMBLY 

    Refer to PROCEDURE - Step 7

  15. REMOVE REAR SEAT CUSHION LOCK HOOK 

    Refer to PROCEDURE - Step 8

  16. REMOVE REAR DOOR SCUFF PLATE RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 14

  17. DISCONNECT REAR DOOR OPENING TRIM WEATHERSTRIP RH 
    1. Disconnect the rear door opening trim weatherstrip RH.
  18. REMOVE REAR UNDER SIDE COVER RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 31

  19. REMOVE REAR SEATBACK HINGE SUB-ASSEMBLY RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 32

  20. REMOVE REAR SEAT SIDE GARNISH RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 33

  21. REMOVE NO. 1 TONNEAU COVER HOLDER CAP 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 41

  22. REMOVE TONNEAU COVER HOOK A 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 35

  23. REMOVE NO. 1 LUGGAGE COMPARTMENT LIGHT ASSEMBLY 

    Refer to PROCEDURE - Step 1

  24. REMOVE DECK TRIM SIDE PANEL ASSEMBLY RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 36

  25. REMOVE NO. 1 HYBRID BATTERY INTAKE DUCT 

    Refer to PROCEDURE - Step 32

  26. REMOVE NO. 2 HYBRID BATTERY INTAKE DUCT 

    Refer to PROCEDURE - Step 33

  27. DISCONNECT AC CHARGER INLET CABLE (w/o CABLE EV CHARGER LOCK ASSEMBLY) 

    See step  27

  28. DISCONNECT AC CHARGER INLET CABLE WITH CABLE EV CHARGER LOCK ASSEMBLY (w/ CABLE EV CHARGER LOCK ASSEMBLY) 

    See step  28

  29. REMOVE FUEL FILLER OPENING LID LOCK BRACKET 

    See step  29

  30. REMOVE EV CHARGER LID SWITCH ASSEMBLY 
    1. Remove the 2 nuts and EV charger lid switch assembly.
      GTY696346Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals