LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2019 >> Prius Prime Plus >> Repair and Diagnosis >> Accessories & Equipment >> Headlights >> Lighting System (Exterior) - Service Information >> Charge Lid Light >> Removal [09/2016 - 05/2019] >> Procedure

Removal [09/2016 - 05/2019]: Procedure

  1. REMOVE TONNEAU COVER ASSEMBLY 

    Refer to PROCEDURE - Step 1

  2. REMOVE REAR NO. 2 FLOOR BOARD 

    Refer to PROCEDURE - Step 2

  3. REMOVE REAR NO. 4 FLOOR BOARD 

    Refer to PROCEDURE - Step 3

  4. REMOVE REAR NO. 3 FLOOR BOARD 

    Refer to PROCEDURE - Step 4

  5. REMOVE REAR NO. 1 FLOOR BOARD 

    Refer to PROCEDURE - Step 5

  6. REMOVE DECK FLOOR BOX LH 

    Refer to PROCEDURE - Step 6

  7. REMOVE DECK FLOOR BOX RH 

    Refer to PROCEDURE - Step 7

  8. REMOVE DECK TRIM SERVICE HOLE COVER 

    Refer to PROCEDURE - Step 2

  9. REMOVE REAR DECK TRIM COVER 

    Refer to PROCEDURE - Step 9

  10. REMOVE REAR SEAT HEADREST ASSEMBLY 

    Refer to PROCEDURE - Step 2

  11. REMOVE REAR SEATBACK HINGE COVER 

    Refer to PROCEDURE - Step 4

  12. REMOVE REAR SEATBACK ASSEMBLY RH 

    Refer to PROCEDURE - Step 5

  13. REMOVE REAR SEAT CUSHION ASSEMBLY RH 

    Refer to PROCEDURE - Step 7

  14. REMOVE REAR SEAT CUSHION LOCK HOOK 

    Refer to PROCEDURE - Step 8

  15. REMOVE REAR DOOR SCUFF PLATE RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 14

  16. DISCONNECT REAR DOOR OPENING TRIM WEATHERSTRIP RH 

    Refer to PROCEDURE - Step 16

  17. REMOVE REAR UNDER SIDE COVER RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 31

  18. REMOVE REAR SEATBACK HINGE SUB-ASSEMBLY RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 32

  19. REMOVE REAR SEAT SIDE GARNISH RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 33

  20. REMOVE ROPE HOOK (w/o Garage Door Opener System) 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 34

  21. REMOVE NO. 2 ROPE HOOK (w/o Garage Door Opener System) 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 35

  22. REMOVE NO. 1 TONNEAU COVER HOLDER CAP (w/ Garage Door Opener System) 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 36

  23. REMOVE TONNEAU COVER HOOK A (w/ Garage Door Opener System) 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 37

  24. REMOVE NO. 1 LUGGAGE COMPARTMENT LIGHT ASSEMBLY 

    Refer to PROCEDURE - Step 1

  25. REMOVE DECK TRIM SIDE PANEL ASSEMBLY RH 

    HINT: 

    Use the same procedure as for the LH side.

    Refer to PROCEDURE - Step 38

  26. REMOVE SPOT LIGHT COVER 
    1. Disengage the 2 claws to remove the spot light cover.
      GTY696343Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  27. REMOVE SPOT LIGHT ASSEMBLY 
    1. Disconnect the connector.
      GTY696342Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Remove the 2 screws and spot light assembly as shown in the illustration.
      GTY691775Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      Remove in this Direction
scientia non olet · About LEMON Manuals