LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2009 >> Highlander Limited, FWD >> Repair and Diagnosis >> Restraints >> Passive Restraints >> Seat Belt (Except Hybrid) >> Rear No. 2 Seat Outer Belt Assembly >> Removal

Rear No. 2 Seat Outer Belt Assembly: Removal

  1. REMOVE REAR DOOR SCUFF PLATE  (See REMOVAL )
  2. DISCONNECT REAR DOOR OPENING TRIM WEATHERSTRIP 
  3. REMOVE DECK BOARD ASSEMBLY  (See REMOVAL )
  4. REMOVE NO. 3 DECK BOARD SUB-ASSEMBLY  (See REMOVAL )
  5. REMOVE NO. 2 DECK BOARD SUB-ASSEMBLY  (See REMOVAL )
  6. REMOVE TONNEAU COVER ASSEMBLY (w/ Tonneau Cover)  (See REMOVAL )
  7. REMOVE REAR SEAT SIDE COVER LH  (See REMOVAL )
  8. REMOVE DECK SIDE TRIM BOX LH  (See REMOVAL )
  9. REMOVE REAR SEAT SIDE COVER RH  (See REMOVAL )
  10. REMOVE JACK CARRIER SUPPORT 
  11. REMOVE JACK CARRIER CUSHION  (See REMOVAL )
  12. REMOVE JACK ASSEMBLY  (See REMOVAL )
  13. REMOVE JACK CARRIER ASSEMBLY  (See REMOVAL )
  14. REMOVE DECK SIDE TRIM BOX RH  (See REMOVAL )
  15. REMOVE REAR MAT  (See REMOVAL )
  16. REMOVE DECK FLOOR BOARD ASSEMBLY  (See REMOVAL )
  17. REMOVE REAR NO. 2 SEAT INNER BELT ASSEMBLY  (See REMOVAL  )
  18. DISCONNECT REAR SEAT LAP TYPE BELT ASSEMBLY LH 
    1. Remove the bolt and disconnect the rear seat lap type belt assembly LH.
  19. DISCONNECT REAR SEAT LAP TYPE BELT ASSEMBLY RH 

    HINT:

    Use the same procedure for the RH side and the LH side.

    Fig 1: Identifying Rear Seat Lap Type Belt Assembly LH Bolt
    G05419471Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  20. REMOVE REAR NO. 2 SEAT ASSEMBLY  (See DISASSEMBLY )
  21. REMOVE REAR FLOOR FINISH PLATE  (See REMOVAL )
  22. REMOVE REAR SEAT SIDE GARNISH CAP (for RH Side without Rear Air Conditioning System)  (See REMOVAL )
  23. REMOVE REAR SEAT SIDE GARNISH CAP (for RH Side with Rear Air Conditioning System)  (See REMOVAL )
  24. REMOVE DECK SIDE TRIM COVER  (See REMOVAL )
  25. REMOVE DECK SIDE TRIM  (See REMOVAL )
  26. REMOVE SIDE TRIM COVER LH (for LH Side without Rear Seat Entertainment System)  (See REMOVAL )
  27. REMOVE POWER OUTLET SOCKET BEZEL (for LH Side with Rear Seat Entertainment System)  (See REMOVAL )
  28. REMOVE SIDE TRIM COVER RH (for RH Side without Rear Automatic Air Conditioning System)  (See REMOVAL )
  29. REMOVE REAR ROOM TEMPERATURE SENSOR (for RH Side with Rear Automatic Air Conditioning System)  (See ROOM TEMPERATURE SENSOR (FOR REAR) )
  30. REMOVE REAR COMBINATION LIGHT SERVICE COVER LH (for LH Side)  (See REMOVAL )
  31. REMOVE REAR COMBINATION LIGHT SERVICE COVER RH (for RH Side)  (See REMOVAL )
  32. REMOVE REAR POWER POINT SOCKET ASSEMBLY (for LH Side)  (See REAR POWER OUTLET SOCKET )
  33. REMOVE REAR POWER OUTLET SOCKET COVER (for LH Side)  (See INSTALLATION )
  34. REMOVE REAR DECK TRIM COVER (for LH Side without Remote Folding Function)  (See REMOVAL )
  35. REMOVE RECLINING REMOTE CONTROL LEVER BEZEL LH (for LH Side with Remote Folding Function)  (See REMOVAL )
  36. REMOVE ROPE HOOK ASSEMBLY  (See REMOVAL )
  37. REMOVE NO. 2 DECK SIDE TRIM HOOK (for LH Side)  (See REMOVAL )
  38. REMOVE NO. 1 LUGGAGE COMPARTMENT TRIM HOOK (for RH Side)  (See REMOVAL )
  39. REMOVE FRONT DECK SIDE TRIM COVER  (See REMOVAL )
  40. REMOVE DECK TRIM SIDE PANEL ASSEMBLY LH (for LH Side)  (See REMOVAL )
  41. REMOVE DECK TRIM SIDE PANEL ASSEMBLY RH (for RH Side)  (See REMOVAL )
  42. REMOVE ROOF SIDE INNER GARNISH ASSEMBLY (w/o Power Back Door)  (See REMOVAL )
  43. REMOVE ROOF SIDE INNER GARNISH ASSEMBLY (w/ Power Back Door)  (See REMOVAL )
  44. REMOVE REAR NO. 2 SEAT OUTER BELT ASSEMBLY 
    1. Remove the bolt and disconnect the shoulder end of the rear No. 2 seat outer belt assembly.
      Fig 2: Identifying Shoulder End Of Rear No. 2 Seat Outer Belt Assembly With Bolt
      G05419472Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Remove the 2 bolts and the rear No. 2 seat outer belt assembly.
scientia non olet · About LEMON Manuals