LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2008 >> Highlander Base, FWD >> Repair and Diagnosis >> Body & Frame >> Exterior Body Panels >> (Door / Hatch) (Except Hybrid) >> Power Back Door Drive Unit >> Installation

Power Back Door Drive Unit: Installation

  1. INSTALL BACK DOOR MOTOR UNIT 
    1. Install the back door motor unit with the 4 bolts and clip.

      Torque: 14 N*m (143 kgf*cm, 10 ft.*lbf) 

      Fig 1: Identifying Back Door Motor Unit Bolts
      G05422343Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
    2. Connect the connector.
    3. Install the back door stay plate and connect the power back door rod.

      Torque: 18 N*m (184 kgf*cm, 13 ft.*lbf) 

      Fig 2: Identifying Power Back Door Rod
      G05422271Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  2. INSTALL BACK DOOR SERVICE HOLE COVER LH  (See REASSEMBLY  )
  3. INSTALL BACK WINDOW UPPER TRIM PANEL ASSEMBLY  (See REASSEMBLY  )
  4. INSTALL ROOF SIDE INNER GARNISH ASSEMBLY LH  (See INSTALLATION )
  5. INSTALL DECK TRIM SIDE PANEL ASSEMBLY LH  (See INSTALLATION )
  6. CONNECT REAR NO. 1 SEAT OUTER BELT ASSEMBLY LH  (See INSTALLATION )
  7. INSTALL FRONT DECK SIDE TRIM COVER LH  (See INSTALLATION )
  8. INSTALL NO. 2 DECK SIDE TRIM HOOK  (See INSTALLATION )
  9. INSTALL ROPE HOOK ASSEMBLY  (See INSTALLATION )
  10. INSTALL REAR DECK TRIM COVER (w/o Remote Folding Function)  (See INSTALLATION )
  11. INSTALL RECLINING REMOTE CONTROL LEVER BEZEL LH (w/ Remote Folding Function)  (See INSTALLATION )
  12. INSTALL REAR POWER OUTLET SOCKET COVER  (See INSTALLATION )
  13. INSTALL REAR POWER POINT SOCKET ASSEMBLY  (See INSTALLATION )
  14. INSTALL REAR COMBINATION LIGHT SERVICE COVER LH  (See INSTALLATION )
  15. INSTALL SIDE TRIM COVER LH (w/o Rear Seat Entertainment System)  (See INSTALLATION )
  16. INSTALL POWER OUTLET SOCKET BEZEL (w/ Rear Seat Entertainment System)  (See INSTALLATION )
  17. INSTALL DECK SIDE TRIM LH  (See INSTALLATION )
  18. INSTALL DECK SIDE TRIM COVER LH  (See INSTALLATION )
  19. INSTALL REAR FLOOR FINISH PLATE  (See INSTALLATION )
  20. INSTALL REAR NO. 2 SEAT ASSEMBLY (w/ Rear No. 2 Seat)  (See INSTALLATION )
  21. CONNECT REAR SEAT LAP TYPE BELT ASSEMBLY LH (w/ Rear No. 2 Seat)  (See INSTALLATION )
  22. CONNECT REAR SEAT LAP TYPE BELT ASSEMBLY RH (w/ Rear No. 2 Seat)  (See INSTALLATION )
  23. INSTALL REAR NO. 2 SEAT INNER BELT ASSEMBLY (w/ Rear No. 2 Seat)  (See INSTALLATION )
  24. INSTALL REAR DECK FLOOR BOX (w/o Rear No. 2 Seat)  (See INSTALLATION )
  25. INSTALL DECK FLOOR BOARD ASSEMBLY (w/o Rear No. 2 Seat)  (See INSTALLATION )
  26. INSTALL REAR MAT  (See INSTALLATION )
  27. INSTALL DECK FLOOR BOARD ASSEMBLY (w/ Rear No. 2 Seat)  (See INSTALLATION )
  28. INSTALL DECK SIDE TRIM BOX LH  (See INSTALLATION )
  29. INSTALL REAR SEAT SIDE COVER LH (w/ Rear No. 2 Seat)  (See INSTALLATION )
  30. INSTALL DECK SIDE TRIM BOX RH  (See INSTALLATION )
  31. INSTALL JACK CARRIER ASSEMBLY  (See INSTALLATION )
  32. INSTALL JACK ASSEMBLY  (See INSTALLATION )
  33. INSTALL JACK CARRIER CUSHION  (See INSTALLATION )
  34. INSTALL JACK CARRIER SUPPORT 
  35. INSTALL REAR SEAT SIDE COVER RH (w/ Rear No. 2 Seat)  (See INSTALLATION )
  36. INSTALL REAR NO. 1 FLOOR BOARD (w/o Rear No. 2 Seat)  (See INSTALLATION )
  37. INSTALL TONNEAU COVER ASSEMBLY (w/ Tonneau Cover)  (See INSTALLATION )
  38. INSTALL NO. 2 DECK BOARD SUB-ASSEMBLY  (See INSTALLATION )
  39. INSTALL NO. 3 DECK BOARD SUB-ASSEMBLY  (See INSTALLATION )
  40. INSTALL DECK BOARD ASSEMBLY  (See INSTALLATION )
  41. INSTALL REAR DOOR OPENING TRIM WEATHERSTRIP LH  (See INSTALLATION )
  42. INSTALL REAR DOOR SCUFF PLATE LH  (See INSTALLATION )
scientia non olet · About LEMON Manuals