LEMON Manuals: Even more car manuals for everyone
Home >> Toyota >> 2008 >> FJ Cruiser RWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 216 (Suspension System) >> Front Stabilizer Bar >> Removal

Front Stabilizer Bar: Removal

WARNING: This page is about a different car, the 2008 Toyota Yaris. However, it is still accessible from the selected car via links, so may be relevant.
  1. DISCONNECT CABLE FROM NEGATIVE BATTERY TERMINAL 
  2. REMOVE HOOD SUB-ASSEMBLY 

    Hatchback: (See REMOVAL )

    Sedan: (See REMOVAL )

  3. REMOVE FRONT WIPER ARM HEAD CAP 

    Hatchback: (See REMOVAL )

    Sedan: (See REMOVAL )

  4. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY LH 

    Hatchback: (See REMOVAL )

    Sedan: (See REMOVAL )

  5. REMOVE FRONT WIPER ARM AND BLADE ASSEMBLY RH 

    Hatchback: (See REMOVAL )

    Sedan: (See REMOVAL )

  6. REMOVE HOOD TO COWL TOP SEAL (for Hatchback) (See  REMOVAL  ) 
  7. REMOVE COWL SIDE VENTILATOR SUB-ASSEMBLY LH (for Sedan) (See  REMOVAL  ) 
  8. REMOVE COWL SIDE VENTILATOR SUB-ASSEMBLY RH (for Sedan) (See  REMOVAL  ) 
  9. REMOVE COWL TOP VENTILATOR LOUVER SUB-ASSEMBLY 

    Hatchback: (See REMOVAL )

    Sedan: (See REMOVAL )

  10. REMOVE COWL TOP VENTILATOR LOUVER LH (for Hatchback) (See  REMOVAL  ) 
  11. REMOVE FRONT WIPER MOTOR AND LINK 

    Hatchback: (See REMOVAL )

    Sedan: (See REMOVAL )

  12. REMOVE COWL TO REGISTER DUCT SUB-ASSEMBLY (for Hatchback) (See  REMOVAL  ) 
  13. REMOVE FRONT AIR SHUTTER SEAL (for Sedan) (See  REMOVAL  ) 
  14. REMOVE OUTER COWL TOP PANEL 

    Hatchback: See REMOVAL

    Sedan: See REMOVAL

  15. POSITION WHEELS FACING STRAIGHT AHEAD 
  16. REMOVE FRONT WHEEL 
  17. REMOVE COLUMN HOLE COVER SILENCER SHEET (See  REMOVAL  ) 
  18. REMOVE STEERING SLIDING YOKE SUB-ASSEMBLY (See  REMOVAL  ) 
  19. REMOVE STEERING COLUMN HOLE COVER SUB-ASSEMBLY (See  REMOVAL  ) 
  20. SEPARATE TIE ROD END SUB-ASSEMBLY LH (See  REMOVAL  ) 
  21. SEPARATE TIE ROD END SUB-ASSEMBLY RH 

    HINT:

    The removal procedure for the RH side is the same as that for the LH side.

  22. SEPARATE FRONT LOWER SUSPENSION ARM LH (See  REMOVAL  ) 
  23. SEPARATE FRONT LOWER SUSPENSION ARM RH 

    HINT:

    The removal procedure for the RH side is the same as that for the LH side.

  24. REMOVE FRONT STABILIZER LINK ASSEMBLY LH 
    1. Remove the 2 nuts and stabilizer link

      HINT:

      If the ball joint turns together with the nut, use a socket hexagon wrench 6 to hold the stud.

  25. REMOVE FRONT STABILIZER LINK ASSEMBLY RH 

    HINT:

    The removal procedure for the RH side is the same as that for the LH side.

    Fig 1: Locating Stabilizer Link Nuts
    G04832095Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  26. SUSPEND ENGINE ASSEMBLY (See  REMOVAL  ) 
  27. REMOVE FRONT SUSPENSION CROSSMEMBER SUB-ASSEMBLY (See  REMOVAL  ) 
  28. REMOVE POWER STEERING GEAR (See  REMOVAL  ) 
  29. REMOVE FRONT STABILIZER BRACKET LH 
    1. Remove the 2 bolts and the stabilizer bracket.
  30. REMOVE FRONT STABILIZER BRACKET RH 
    1. Remove the 2 bolts and the stabilizer bracket.
  31. REMOVE FRONT STABILIZER BAR 
  32. REMOVE FRONT STABILIZER BAR BUSH 
    Fig 2: Locating Stabilizer Bracket Bolts
    G04832096Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
scientia non olet · About LEMON Manuals