LEMON Manuals: Even more car manuals for everyone
Home >> Smart >> 2017 >> Fortwo Electric Drive, 2D Convertible >> Repair and Diagnosis (Single Page) >> Accessories & Equipment >> Mirrors >> Detachable Body Components - 453 Chassis >> Testing & Repair >> Disassemble/Assemble Front Bumper - AR88.20-P-2050SRA

Disassemble/Assemble Front Bumper - AR88.20-P-2050SRA

MODEL 453.3/4 

G12097135Courtesy of MERCEDES-BENZ USA

Shown with code V07 (Front fog lamp (FFO)) and code 252 (COLLlSlON PREVENTiON ASSlST) 

G12097136Courtesy of MERCEDES-BENZ USA

Shown except code V07 (Front fog lamp (FFO)) and except code 252 (COLLISION PREVENTION ASSIST) 

G12097137Courtesy of MERCEDES-BENZ USA

Shown except code V07 (Front fog lamp (FFO)) 

REMOVING Remove     
1 Remove front bumper (1) and lay down on suitable subsurface   AR88.20-P-2000SRA 
DISASSEMBLINGASSEMBLING Disassemble/assemble     
2 Remove license plate and license plate brackets    
3 Disconnect electrical connectors (20)    
4 Disconnect electrical connectors (21) Model 453.3/4
with code V07 (Front fog lamps (FFO))
 
5 Disconnect electrical connection (22) Model 453.3/4
with code 252 (COLLISION PREVENTION ASSIST)
 
6 Expose electrical wiring harness (2) and remove INSTALLATION IMPORTANT : Observe line routing.
SPECIAL TOOL Clip remover
Figure
7 Unscrew bolts (3) and remove left turn signal lamp (E6/1) and right turn signal lamp (E6/2)    
8 Remove radiator grille (4)   AR88.40-P-4001SRA 
9.1 Unscrew bolts (5) and remove covers (6) in direction of arrow Model 453.3/4
except code V07 (Front fog lamps (FFO))
 
9.2 Unscrew bolts (5) and remove left front fog lamp (E5/1) and right front fog lamp (E5/2) in direction of arrow Model 453.3/4
with code V07 (Front fog lamps (FFO))
 
10 Press barb on towing eye cover (7) together and remove towing eye cover (7)    
11 Unclip retaining clips (8)    
12 Unclip retaining clips (9)    
13 Unclip retaining clips (10) and remove lower radiator grille (11)    
14 Drill off heads of rivets (12) NOTES Do not drill out rivet heads of rivets (12) too far. Otherwise the lower front compartment cover (13) can be damaged and must be replaced.
IMPORTANT Use 7 mm dia. bit.
 
15 Unclip lower front compartment cover (13) and remove SPECIAL TOOL Mounting wedge Fig 2
16 Unclip center wind deflector (14) and remove    
17 Unclip retaining clips (15)    
18 Unclip front spoiler (16) SPECIAL TOOL Mounting wedge Fig 2
19 Remove rests of rivet from rivets (12)    
20 Assemble in the reverse order    
INSTALLING Install     
21 Install front bumper (1)   AR88.20-P-2000SRA 
Fig 1: Identifying Clip Remover (452 589 01 63 00)
G09980802Courtesy of MERCEDES-BENZ USA
Fig 2: Identifying Mounting Wedge (110 589 03 59 00)
G07079389Courtesy of MERCEDES-BENZ USA