LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2019 >> S450 Base >> Repair and Diagnosis >> Engine Mechanical >> Mechanical >> Engine Suspension - 222 Chassis >> Testing & Repair >> Remove/Install Front Engine Mount >> Remove/Install Front Engine Mount - AR22.10-P-4330MNP

Remove/Install Front Engine Mount - AR22.10-P-4330MNP

Engine 176 in model 217, 222 

Engine 177 in model 217, 222 

MODIFICATION NOTES

06.12.2019 Document completely revised.    

Shown on model 222 with engine 176 and code M005 

Fig 1: Front Engine Mount Components Location - Engine 176, 177 In Model 222 (Shown With Engine 176 And Code M005)
G15362638WARNINGWARNINGCAUTIONCAUTIONREMOVINGINSTALLINGTORQUE SPECIFICATIONSPECIAL TOOLNOTESNOTESINSTALLATION IMPORTANTSPECIAL TOOLSPECIAL TOOLNOTESTORQUE SPECIFICATIONIMPORTANTIMPORTANTWARNINGCAUTIONREFER TO CAPACITIES & SPECIFICATIONSSPECIAL TOOLSPECIAL TOOLSPECIAL TOOLSPECIAL TOOLSPECIAL TOOLCourtesy of MERCEDES-BENZ USA
WARNING Risk of injury.  Moving parts can pinch, crush or, in extreme cases even sever extremities. No parts of the body or limbs should be within the operating area of mechanical components when moving components. AS00.00-Z-0009-01A
WARNING Risk of injury.  Skin or eye injuries may result when handling hot or glowing objects. Wear protective gloves, protective clothing and safety glasses, if necessary. AS00.00-Z-0002-01A
CAUTION Risk of injury  caused by scraping or cutting body parts on sharp vehicle parts Always wear protective gloves when working on or near sharp and non-deburred vehicle parts.
Deburr repair panels.
AS00.00-Z-0017-01A
CAUTION Risk of injury  to skin and eyes due to handling of engine oil. Risk of poisoning  caused by swallowing engine oil Wear protective gloves, protective clothing and safety glasses.
Do not fill engine oil into beverage containers.
AS18.00-Z-0001-01A
Notice  Notes on bolted connections with self tapping screws   AH00.00-P-0007-01SF
Notice  Notes on avoiding damage through contamination and foreign objects   AH00.00-P-5000-01A
Notice  Notes on threaded connections fastened using a tightening angle-based tightening process   AH00.00-P-0020-01A
Notice  Notes on self-locking nuts and bolts   AH00.00-P-0001-01KOA
  Notes on repair work on suspension components   AH00.00-P-0100-01A
REMOVINGINSTALLING Remove/install     
1 Secure vehicle on vehicle lift.   AR00.60-P-0100CW
2 Attach engine hoist.   AR33.10-P-0105MNP
3 Remove front axle shafts. Engine 176, 177 in model 217, 222
with code M005 (Vehicles with 4MATIC/all-wheel drive)
AR33.30-P-0620LFX
4 Unscrew the screw (4) for the engine carriers (5) TORQUE SPECIFICATION Engine 176 in model 217
with code M005 (Vehicles with 4MATIC/all-wheel drive)
Engine 176 in model 222
with code M005 (Vehicles with 4MATIC/all-wheel drive)
except code Z07 (B7 armoring on special protection version)
Engine 176 in model 222
with code M005 (Vehicles with 4MATIC/all-wheel drive)
with code Z07 (B7 armoring on special protection version) Bolt, front engine mount to engine support
*BA22.10-P-1001-03K 
5.1 Disconnect steering coupling. Model 217 with engine 176, 177
Model 222 as of 4/30/14 with engine 176, 177
 
      AR46.10-P-8000-01LW
    SPECIAL TOOL Engine mount wrench set Fig 6
5.2 Remove steering coupling. Model 222 up to 4/29/14 with engine 176, 177  
      AR46.10-P-8000RK
6 Release transmission oil lines from the engine and from the transmission and place to one side. Model 217, 222 with engine 177 with transmission 725.0 AR27.55-P-0600MNM
    Model 217, 222 with engine 176 with transmission 725.0
NOTES Do not subject the lines to tension. Damage and function impairments will otherwise occur.
AR27.55-P-0600MNK
7 Tighten tensioning screw of the engine hoist and lift engine carefully as far as possible. NOTES Do not put electrical lines and hoses under tension.
Damage and function impairments will otherwise occur.
INSTALLATION IMPORTANT:  Ensure that the engine mounts (1) extend into the engine carriers (5).
 
    SPECIAL TOOL Engine lifting device Fig 8
    SPECIAL TOOL Lifting eye Fig 5
8 Carefully lower front axle by 16 cm. Engine 176, 177 in model 217, 222
with code M005 (Vehicles with 4MATIC/all-wheel drive)
 
      AR33.10-P-0101LF
    NOTES
Do not kink or crush lines or subject lines to tension.
Otherwise, the lines will be damaged and there will be function impairments.
 
9 Remove screw (2, 3). TORQUE SPECIFICATION Engine 176 in model 217
with code M005 (Vehicles with 4MATIC/all-wheel drive)
Engine 176 in model 222
with code M005 (Vehicles with 4MATIC/all-wheel drive)
except code Z07 (B7 armoring on special protection version)
Engine 176 in model 222
with code M005 (Vehicles with 4MATIC/all-wheel drive)
with code Z07 (B7 armoring on special protection version) Screw/bolt, front engine mount to front axle carrier
*BA22.10-P-1002-03K 
10 Remove engine mounts (1) to the lower rear. IMPORTANT Note the installation position of the engine mounts (1), mark if needed.
Always replace engine mounts (1) in pairs.
IMPORTANT Pay attention to environmental protection regulations for disposal of engine mounts (1). Dispose of engine mounts (1) into mixed scrap
 
11 Install in the reverse order.    
  Finishing activity     
12 Perform wheel alignment measurement. Engine 176, 177 in model 217, 222
with code M005 (Vehicles with 4MATIC/all-wheel drive)
 
      AR40.20-P-0200LF
WARNING Risk of accident  from vehicle starting off by itself when engine running. Risk of injury  (bruises and burns) resulting from working on the engine while it is being started or when it is running. Secure vehicle to prevent it from starting off by itself. Wear closed and snug-fitting work clothes. Do not touch hot or rotating parts. AS00.00-Z-0005-01A
CAUTION Risk of injury  to skin and eyes due to handling of transmission oil. Health risk caused by swallowing transmission oil Rear protective gloves, protective clothing and safety glasses.
Do not pour transmission oil into beverage bottles.
AS00.40-Z-0001-01A
13 Check transmission oil level and correct if necessary. Engine 176, 177 in model 217, 222
except code M005 (Vehicles with 4MATIC/all-wheel drive)
 
  Notes on oil pan versions   AH27.10-P-0002-01EWN
REFER TO CAPACITIES & SPECIFICATIONS Automatic transmission fluids (ATF) (specification 236.17)   BB00.40-P-0236-17A
      AR27.00-P-0270-02EWN
    MB Plastilube brake paste (brownish) *BR00.45-Z-1084-06A 
    Assembly cleaner *BR00.45-Z-1028-04A 
    SPECIAL TOOL Oil dispenser Fig 9
    SPECIAL TOOL Socket wrench Fig 7
    SPECIAL TOOL Adapter Fig 3
    SPECIAL TOOL Socket wrench Fig 2
    SPECIAL TOOL Oil level sensor Fig 4
ENGINE MOUNT, ENGINE SUPPORT (ENGINE SIDE)

Number Designation Model 217 with engine 157, 176, 177, 278, 279 Model 222 except code Z07 (B7 armoring on special protection version)
BA22.10-P-1001-03K Bolt, front engine mount to engine support M10 Stage 1 Nm 45 50
Stage 2 ∠ 120 -
M12 Stage 1 Nm 45 45
Stage 2 ∠ 120 120
ENGINE MOUNT, ENGINE SUPPORT (ENGINE SIDE)

Number Designation Model 222
with code Z07 (B7
armoring on special protection version)
BA22.10-P-1001-03K Bolt, front engine mount to engine support M10 Stage 1 Nm 50
Stage 2 ∠ -
M12 Stage 1 Nm 45
Stage 2 ∠ 125
ENGINE MOUNT, ENGINE SUPPORT (ENGINE SIDE)

Number Designation Model 217 with engine 157, 176, 177, 278, 279 Model 222 except code Z07 (B7 armoring on special protection version)
BA22.10-P-1002-03K Screw/bolt, front engine mount to front axle carrier Nm 30 30
ENGINE MOUNT, ENGINE SUPPORT (ENGINE SIDE)

Number Designation Model 222
with code Z07 (B7
armoring on special protection version)
BA22.10-P-1002-03K Screw/bolt, front engine mount to front axle carrier Nm 30
Fig 2: Identifying Socket Wrench (724 589 01 09 00)
G13657102Courtesy of MERCEDES-BENZ USA
Fig 3: Identifying Adapter (725 589 00 90 00)
G12935427Courtesy of MERCEDES-BENZ USA
Fig 4: Identifying Oil Level Sensor (000 588 09 19 00)
G15347569Courtesy of MERCEDES-BENZ USA
Fig 5: Identifying Lifting Eye (177 589 00 62 00)
G13655206Courtesy of MERCEDES-BENZ USA
Fig 6: Identifying Engine Mount Wrench Set (001 589 01 16 00)
G12929968Courtesy of MERCEDES-BENZ USA
Fig 7: Identifying Socket Wrench (725 589 00 09 00)
G11971897Courtesy of MERCEDES-BENZ USA
Fig 8: Identifying Engine Lifting Device (240 589 00 61 00)
G13655194Courtesy of MERCEDES-BENZ USA
Fig 9: Identifying Oil Dispenser (000 588 06 82 00)
G15347574Courtesy of MERCEDES-BENZ USA
REPAIR MATERIALS

Number Designation Order number
BR00.45-Z-1028-04A Assembly cleaner A 000 986 56 01
BR00.45-Z-1084-06A MB Plastilube brake paste (brownish) A 002 989 37 51