LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2017 >> GLS550 >> Repair and Diagnosis >> Suspension >> Suspension Control Systems >> Suspension - 166 Chassis 2 Of 2 >> Testing & Repair >> Remove/Install Rear Axle Active Roll Stabilization Valve Support - AR32.34-P-5030GQX

Remove/Install Rear Axle Active Roll Stabilization Valve Support - AR32.34-P-5030GQX

Model 166.8 

with code 468 (ACTIVE CURVE SYSTEM) 

G14238347Courtesy of MERCEDES-BENZ USA
Fig 1: Rear Axle Active Roll Stabilization Valve Support Components Location - Model 166.8 With Code 468
G14238348Courtesy of MERCEDES-BENZ USA
G14238349Courtesy of MERCEDES-BENZ USA
REMOVINGINSTALLING Remove/install     
WARNING Risk of injury  to skin or eyes from hydraulic fluid spraying out under pressure. Risk of poisoning  from swallowing hydraulic fluid. Depressurize hydraulic system completely before starting any work on it. Wear protective clothing and safety glasses. AS00.00-Z-0013-01A
Notes on repair work on suspension components   AH00.00-P-0100-01A
Notes on active roll stabilization   AH32.34-P-0001-01A
Notes on self-locking nuts and bolts   AH00.00-N-0001-01A
1 Secure vehicle on vehicle lift   AR00.60-P-0100GZ
2 Deflate air springs with STAR DIAGNOSIS    
Notes on AIRmatic   AH32.22-P-1000-02GZ
REFER TO SELF-DIAGNOSTIC SYSTEMS   NOTES Deflate air springs in line with specifications; the wheel-and-tire assemblies must not touch the ground.
The air springs can otherwise be damaged and fail later.
AD00.00-P-2000-04A
3 Detach right rear wheel-and-tire assembly    
REFER TO MAINTENANCE     AP40.10-P-4050EW
4 Remove corresponding underfloor paneling    
5 Remove AdBlue® tank Model 166.8 with engine 642 with code 468 (ACTIVE CURVE SYSTEM)
with code U42 (BlueTEC diesel exhaust treatment (SCR))
AR14.40-P-2014GQ
6 Detach lines (4)   AR32.00-P-0001-01A
    Assembly cleaner *BR00.45-Z-1028-04A 
    SPECIAL TOOL Record plug Fig 4
    SPECIAL TOOL Detaching tool Fig 3
    SPECIAL TOOL Detaching tool Fig 2
7 Expose brake line from bracket (5)    
8 Unfasten line for electric parking brake (6) from bracket    
9 Detach drive shaft from differential IMPORTANT Flexible coupling remains on drive shaft. AR41.10-P-0050GQ
10 Support differential    
REFER TO SPECIAL TOOLS 000 588 11 62 00 Major assembly mount   WS01.00-P-0092B
REFER TO SPECIAL TOOLS 000 588 10 62 00 Support plate   WS26.00-P-3309B
11 Detach shock absorbers from right lower control arm (8) TORQUE SPECIFICATION Screw/self-locking nut, shock absorber to spring link *BA32.25-P-1001-03K 
12 Remove bolts (7) of rear axle fastening and lower rear axle INSTALLATION IMPORTANT If the side board end stop (24b) is fitted, check it is correctly seated.  
    TORQUE SPECIFICATION Self-locking bolt, rear axle carrier at front and rear to frame floor assembly *BA35.10-P-1001-01K 
13 Detach lines (1) from valve support (2)   AR32.00-P-0001-01A
    Assembly cleaner *BR00.45-Z-1028-04A 
    TORQUE SPECIFICATION Screw/bolt, oil line to valve block on front axle/rear axle *BA32.34-P-1008-01A 
    SPECIAL TOOL Record plug Fig 4
14 Mark, release and disconnect electrical connections (3)    
15 Unscrew bolts (2s) and remove valve support (2)    
16 Detach bracket from valve support (2) and rear axle carrier If necessary
TORQUE SPECIFICATION Screw/bolt, bracket to rear axle valve support
*BA32.34-P-1005-01A 
    TORQUE SPECIFICATION Screw/bolt, bracket to rear axle valve block *BA32.34-P-1004-01A 
INSPECT Check     
17 Check elastomer bearing (2g) of valve support (2) IMPORTANT Check elastomer bearing (2g) for wear, damage and correct seating, and replace if necessary.  
18 Install in the reverse order    
19 Fill and bleed ACTIVE CURVE SYSTEM   AR32.34-P-0021GQ 
REAR AXLE SHOCK ABSORBER

Number Designation Model 166 except code 489 (AIRMATIC)
BA32.25-P-1001-03K Screw/self-locking nut, shock absorber to spring link Stage 1 Nm 180
Stage 2 ∠° 90
ACTIVE ROLL STABILIZATION

Number Designation Model 166
BA32.34-P-1004-01A Screw/bolt, bracket to rear axle valve block Nm 8
ACTIVE ROLL STABILIZATION

Number Designation Model 166
BA32.34-P-1005-01A Screw/bolt, bracket to rear axle valve support Nm 8
ACTIVE ROLL STABILIZATION

Number Designation Model 166
BA32.34-P-1008-01A Screw/bolt, oil line to valve block on front axle/rear axle Nm 20
REAR AXLE CARRIER

Number Designation Model 166
BA35.10-P-1001-01K Self-locking bolt, rear axle carrier at front and rear to frame floor assembly M14X1.5 Stage 1 Nm 100
Stage 2 ∠° -180
Stage 3 Nm 100
Stage 4 ∠° 90
Fig 2: Identifying Detaching Tool (221 589 01 33 00)
G14238350Courtesy of MERCEDES-BENZ USA
Fig 3: Identifying Detaching Tool (230 589 01 33 00)
G14238351Courtesy of MERCEDES-BENZ USA
Fig 4: Identifying Set Of Stop Plugs (129 589 00 91 00)
G14238352Courtesy of MERCEDES-BENZ USA
REPAIR MATERIALS

Number Designation Order number
BR00.45-Z-1028-04A Assembly cleaner A 000 986 56 01