Remove And Install Right Front Wheelhouse Paneling - Ar62.20-P-1223GW
Model 463
as of model year 2013 up to model year 2019
Shown on model 463 up to model year 2015
Shown on model 463 up to model year 2015
Shown on MODEL 463 as of model year 2016
| Risk of injury caused by scraping or cutting body parts on sharp vehicle parts | Always wear protective gloves when working on or near sharp and non-deburred vehicle parts. Deburr repair panels. |
AS00.00-Z-0017-01A | |
| Risk of injury
to skin and eyes suffering scalding from contact with hot coolantspray. Risk of poisoning from swallowing coolant. |
Do not open cooling system unless coolant temperature is below 90°C. Open cap slowly and release the pressure. Do not pour coolant into beverage containers. Wear protective gloves, protective clothing and safety glasses. |
AS20.00-Z-0001-01A | |
| Information on preventing damage to electronic components due to electrostatic discharge | AH54.00-P-0001-01A | ||
| Notes on coolant | AH20.00-N-2080-01A | ||
| Notes on self-locking nuts and bolts | AH00.00-N-0001-01A | ||
| Remove/install | |||
| 1 | Switch off ignition and store all transmitter keys outside the transmitter range (at least 2 m). | ||
| 2 | Disconnect ground line from battery. | Model 463.241 as of model year 2013 up to model year 2019 with code 979 (Special protection MB Guard) with code E26 (Auxiliary battery) with code ZS4 (Special protection version FB4) Model 463.241 as of model year 2013 up to model year 2019 with code 979 (Special protection MB Guard) with code E26 (Auxiliary battery) with code ZS6 (Special protection version FB6) Model 463.241 as of model year 2013 up to model year 2019 with code 979 (Special protection MB Guard) with code E26 (Auxiliary battery) with code ZS7 (Special protection version FB7) |
AR54.10-P-0003PV |
| Model 463.236/248 as of model year 2013 up to model year 2015 with code 979 (Special protection MB Guard) with code E26 (Auxiliary battery) with code ZS6 (Special protection version FB6) Model 463.236/248 as of model year 2013 up to model year 2015 with code 979 (Special protection MB Guard) with code E26 (Auxiliary battery) with code ZS7 (Special protection version FB7) Model 463.242 as of model year 2013 up to model year 2015 with code E26 (Auxiliary battery) |
AR54.10-P-0003PM | ||
| Model 463 (except 463.234/236/241/242/248) as of model year 2013 up to model year 2019 |
AR54.10-P-0003GW | ||
| 3 | Open engine hood and position upright. | AR88.40-P-1000GG | |
| 4 | Remove right engine intake duct (7). | ||
| 5 | Remove right front fender. | AR88.10-P-1000GW | |
| 6 | Remove differential lock vacuum pump. | Model 463 as of model year 2013 up to model year 2016 |
AR28.18-P-0001GW |
| 7 | Remove radiator crossmember. | AR62.30-P-2300GW | |
| 8 | Remove the coolant expansion reservoir. | Model 463.202/222/236/237 with engine 273.963 as of model year 2013 up to model year 2019 |
AR20.30-P-4950GR |
| Model 463 with engine 176 as of model year 2016 up to model year 2019 |
AR20.30-P-4950MNA | ||
| Model 463 with engine 157 as of model year 2013 up to model year 2019 |
AR20.30-P-4950GW | ||
| Model 463 with engine 642 (except 642.887) as of model year 2013 up to model year 2019 |
AR20.30-P-4950GY | ||
| 9.1 | Remove coolant circulation pump (M13). | Model 463 as of model year 2013 up to model year 2016 |
AR83.25-P-1170GW |
| 9.2 | Remove ME-SFI [ME] control unit (N3/10). | Model 463 with engine 176 as of model year 2016 up to model year 2019 |
AR07.08-P-1000MNF |
| 10 | Remove engine compartment prefuse box (F32/3) and place to one side with connected lines. | ||
| 11 | Remove right front wheel arch ground point (W3/1). | ||
| 12 | Remove air plenum chamber and air/water duct. | Model 463 as of model year 2013 up to model year 2019 |
AR83.10-P-9998GW |
| 13 | Remove washer fluid reservoir of windshield washer system. | Model 463 as of model year 2013 up to model year 2019 |
AR82.35-P-6000GW |
| 14 | Remove front bumper. | Model 463 as of model year 2016 up to model year 2019 with code C13 (Front bumper in steel) |
AR88.20-P-2000GWB |
| Model 463 as of model year 2013 up to model year 2016 except code 990 (AMG car docs./desig. plate allocation) |
AR88.20-P-2000GWC | ||
| Model 463 as of model year 2016 up to model year 2019 except code 990 (AMG car docs./desig. plate allocation) except code C13 (Front bumper in steel) |
AR88.20-P-2000GWA | ||
| Model 463 as of model year 2013 up to model year 2019 with code 990 (AMG car docs./desig. plate allocation) except code C13 (Front bumper in steel) |
AR88.20-P-2000GW | ||
| 15.1 | Remove hood catch. | Model 463 as of model year 2013 up to model year 2016 |
AR88.40-P-3200GW |
| 15.2 | Remove right hood catch. | Model 463 as of model year 2016 up to model year 2019 |
AR88.40-P-3200GWA |
| 16 | Remove refrigerant line (1) and receiver drier (2) from wheel well paneling (3). | ||
| 17 | Remove coolant hoses (6) from wheel well paneling (3). | ||
| 18 | Remove coolant pipe (8) from wheel well paneling (3). | ||
| 19 | Release and disconnect brake pad wear display FRT RH sensor electrical connector (X88/13). | ||
| 20.1 | Release and disconnect electrical connector of right horn (H2/1). | Model 463 as of model year 2013 up to model year 2016 |
|
| 20.2 | Release and disconnect electrical connectors of right horns. | Model 463 as of model year 2016 up to model year 2019 |
|
| 21 | Pull electrical wiring harness (4) and hose line (5) to the inside through wheel well paneling (3). | ||
| 22 | Remove crossbar (10). | Model 463 as of model year 2013 up to model year 2016 |
|
| 23 | Remove screws (11). | Model 463 as of model year 2013 up to model year 2016 |
|
| 24 | Unscrew screw (12) for attachment of wheel well paneling (3) at frame. | *BA60.80-P-1002-01A | |
| 25 | Remove cover panel (14). | ||
| 26 | Remove screws (15). | ||
| 27 | Unscrew nuts (13). | ||
| 28 | Disconnect other connections at wheel well paneling (3) from engine, firewall and front-end assembly. | ||
| 29 | Remove wheel well paneling (3). | ||
| 30 | Install in the reverse order. | ||
| Filling | |||
| 31 | Fill in coolant. | Model 463 with engine 176 as of model year 2016 up to model year 2019 |
AR20.00-P-1142MNF |
| Model 463 with engine 157 as of model year 2013 up to model year 2019 |
AR20.00-P-1142GW | ||
| Model 463 with engine 273, 642.886/970 as of model year 2013 up to model year 2019 |
AR20.00-P-1142GX | ||
| Check | |||
| 32 | Check engine cooling system for leak tightness. | Model 463 with engine 273 as of model year 2013 up to model year 2019 |
AR20.00-P-1010GZC |
| Model 463 with engine 176, 642 as of model year 2016 up to model year 2019 |
AR20.00-P-1010MNF | ||
| Model 463 with engine 157 as of model year 2013 up to model year 2019 |
AR20.00-P-1010GW |
CAB, CAB MOUNTING
| Number | Designation | Model 463 up to model year 2019 | |
|---|---|---|---|
| BA60.80-P-1002-01A | Bolt, body to frame | Nm | 43 |