Electrical System, Equipment & Instruments - 212 Chassis - 3 Of 6
- Testing & Repair
- Perform flash test and insulation resistance test - AR54.10-P-0018-01LF
- Remove/install cigarette lighter
- Remove/install 12V socket at front of vehicle interior - AR54.10-P-1003EW
- Remove/install 12V socket of rear center console - AR54.10-P-1004EW
- Perform manual power disconnect for high-voltage on-board electrical system
- Maintaining on-board electrical system voltage when performing test and diagnosis work on vehicle - AR54.10-P-1127CW
- Check condition of additional battery - AR54.10-P-1128EW
- Check battery - AR54.10-P-1129-01A
- Check battery voltage by means of the instrument cluster (IC) - AR54.10-P-1129-02CWB
- Reduce increased voltage after charging process - AR54.10-P-1129-03A
- Check condition of battery - AR54.10-P-1129CW
- Charge battery - AR54.10-P-1130CW
- Check battery condition before vehicle delivery - AR54.10-P-1132A
- Check high-voltage battery
- Remove/install high-voltage battery - AR54.10-P-1140EH
- Perform diagnosis on removed high-voltage battery - AR54.10-P-1144NKE
- Perform disable/initial startup for high-voltage on-board electrical system - AR54.10-P-1150EH
- Perform measurement of insulation resistance on high-voltage on-board electrical system - AR54.10-P-1160-01LF
- Charge high-voltage battery - AR54.10-P-1170EH
- Remove/install pyrofuse - AR54.10-P-1180EH
- Perform measurement of insulation resistance - AR54.10-P-4000EH
- Remove/install pyrofuse electrical connector - AR54.15-P-1100EW
- Remove/install front prefuse box - AR54.15-P-1330EW
- Remove/install rear prefuse box - AR54.15-P-1340EW
- Remove/install additional battery relay - AR54.15-P-2000EW
- Repair wiring harness by means of axial solder connectors - AR54.18-P-0100-06A
- Checking wiring harness - AR54.18-P-0600-01A
- Repair supplemental restraint system (SRS) squib wiring harness - AR54.18-P-0600A
- Programming of control units
- SCAN coding of control units - AR54.21-P-0015X
- Remove/install chassis Gateway control unit - AR54.21-P-0060EW
- Remove/install SAM control unit with fuse and relay box in trunk - AR54.21-P-1258EW
- Remove/install left front SAM control unit with fuse and relay box - AR54.21-P-1260CW
- Remove/install upper control panel control unit - AR54.21-P-1262CY
- Remove/install multifunction camera - AR54.21-P-3000EW
- Separate/connect electrical connector at steering column switch module - AR54.25-P-2802-02CW
- Remove/install steering column module - AR54.25-P-2802EW
- Remove/install light switch module
- Perform adjustments to the control system
- Remove/install Night View Assist control unit - AR54.30-P-3000SX
- Remove/install 360° front camera - AR54.30-P-3001ECM
- Remove/install 360° camera in outside mirror - AR54.30-P-3002ECM
- Remove/install 360° camera control unit - AR54.30-P-3004EWM
- Remove/install Night View Assist control unit - AR54.30-P-3100EW
- Remove/install instrument cluster - AR54.30-P-6015EW
- Remove/install fanfare horns
- Remove/install Parktronic system (PTS) sensors in front bumper - AR54.65-P-0001EW
- Remove/install Parktronic system (PTS) sensors in rear bumper - AR54.65-P-0002EW
- Remove/install Parktronic system (PTS) control unit - AR54.65-P-0006CW
- Calibration of the backup camera - AR54.65-P-0022GZ
- Remove/install backup camera - AR54.65-P-0030EW
- Remove/install voltage supply of backup camera - AR54.65-P-0032EW
- Remove/install radar sensors control unit
- Remove/install sensors for Blind Spot Assist
- Remove/install radar sensor for Lane Assistant in rear bumper - AR54.71-P-0200ECM
- Test & Adjustment Values
- Maintenance
- Overview - Check condition of battery - AP54.10-P-5449U
- Check warning lamps and function indicator lamps in the instrument cluster, general view - AP54.30-P-5449U
- Check warning and function indicator lamps in instrument cluster - AP54.30-P-5451EW
- Check warning lamps, indicator lamps and interior illumination - AP54.30-P-5452C
- Check lamps in instrument cluster and interior illumination - AP54.30-P-5453EW
- Retrofitting & Conversion
- Retrofit headlamp wiring harness - AN54.30-P-0001-01EW
- Retrofit Night View Assist wiring harness - AN54.30-P-0001-02EW
- Retrofit Night View Assist control unit - AN54.30-P-0001-03EW
- Retrofit Night View Assist - AN54.30-P-0001EW
- Retrofit multifunction camera wiring harness - AN54.30-P-0100-01EW
- Retrofit Speed Limit Assist - AN54.30-P-0100EC
- Retrofit backup camera control unit - AN54.65-P-0030-01EW
- Retrofit the backup camera wiring harness
- Retrofit reversing camera power supply module - AN54.65-P-0030-06ES
- Retrofit reversing camera