LEMON Manuals: Even more car manuals for everyone
Home >> Mercedes Benz >> 2008 >> GL320 4WD >> Repair and Diagnosis >> External Pages >> Different car >> Section 4 (Throttle/Speed Control - 164 Chassis) >> Testing & Repair >> Remove/install the electronic accelerator actuator with flap connection - AR30.20-P-1262GZA

Remove/install the electronic accelerator actuator with flap connection - AR30.20-P-1262GZA

WARNING: This page does not describe the selected car, but rather 28 other vehicles, including the 2012 Mercedes-Benz GL550, 2012 Mercedes-Benz GL450, 2011 Mercedes-Benz ML63, 2011 Mercedes-Benz ML550, and 2011 Mercedes-Benz ML350. However, it is still accessible from the selected car via links, so may be relevant.

ENGINE 272, 273 in MODEL 164 

Fig 1: Identifying Electronic Accelerator Actuator With Flap Connection Remove/Install Components
G05259999Courtesy of MERCEDES-BENZ OF NORTH AMERICA.
REMOVINGINSTALLING Remove/install    
DANGER Risk of injury  caused by fingers being jammed or pinched  when removing, installing or aligning hoods, doors, trunk lid/rear-end door or sliding roof. When moving components, ensure that no body parts or limbs are within the operating range of moving parts. AS00.00-Z-0011-01A
1 Open engine hood and raise to vertical position   AR88.40-P-1000GZ
2.1 Remove strut brace IMPORTANT Only model 164.8. AR62.30-P-2500GY
3 Remove air filter housing   AR09.10-P-1150GZA
4 Remove hot film mass air flow sensor   AR07.07-P-1453GZA
5 Remove air duct housing   AR09.20-P-0080GZA
6 Detach vent line (1) from throttle valve actuator (M16/6)    
7 Disconnect plug (3) from plug shoe on throttle valve actuator (M16/6) IMPORTANTInstallation:  Coat the electrical connector with contact fluid.  
    Contact fluid *BR00.45-Z-1001-14A 
8 Unscrew bolt (2) TORQUE SPECIFICATION *BA07.61-P-1001-01D 
9 Remove throttle valve actuator (M16/6) IMPORTANTInstallation:  Install new gasket  
10 Install in the reverse order    
11 Read out fault memory and erase if required STAR DIAGNOSIS diagnosis system *WH58.30-Z-1048-13A 
REFER TO SELF-DIAGNOSTIC SYSTEMS Connect up STAR DIAGNOSIS and read out fault memory   AD00.00-P-2000-04A
ME-SFI FUEL INJECTION AND IGNITION SYSTEM

Number Designation Engine 272 Engine 273
BA07.61-P-1001-01D Bolt, throttle valve actuator to resonance intake manifold Nm 9 9
COMMERCIALLY AVAILABLE TOOLS

Number Designation
WH58.30-Z-1048-13A STAR DIAGNOSIS diagnosis system, Compact Passenger Car 6511 1801 00
REPAIR MATERIALS

Number Designation Order number
BR00.45-Z-1001-14A Contact fluid A 008 989 55 71
scientia non olet · About LEMON Manuals