LEMON Manuals: Even more car manuals for everyone
Home >> Lexus >> 2022 >> NX 450h+ Base >> Repair and Diagnosis >> Restraints >> Seat Belts >> Seat Belt - Service Information >> Rear Seat Outer Belt Assembly With Pre-TENSIONER >> Removal [11/2021 - ] >> Procedure

Removal [11/2021 - ]: Procedure

  1. PRECAUTION 
    WARNING:

    Be sure to read Precaution thoroughly before servicing.

    GTY607029Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002

    Refer to PRECAUTION [11/2021 - ]

    NOTE:

    After the ignition switch is turned off, there may be a waiting time before disconnecting the negative (-) auxiliary battery terminal.

    Refer to BEFORE DISCONNECTING BATTERY [11/2021 - ]
  2. REMOVE BATTERY SERVICE COVER PLATE 

    Refer to PROCEDURE - Step 2

  3. DISCONNECT CABLE FROM NEGATIVE AUXILIARY BATTERY TERMINAL 
    WARNING:
    • Wait at least 60 seconds after disconnecting the cable from the negative (-) auxiliary battery terminal to disable the SRS system.
    • If an airbag deploys for any reason, it may cause a serious injury.
    GTY684647Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002

    Refer to PROCEDURE - Step 3

  4. REMOVE TONNEAU COVER ASSEMBLY 

    Refer to PROCEDURE - Step 1 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 1 [03/2024 - ]

  5. REMOVE DECK BOARD ASSEMBLY 

    Refer to PROCEDURE - Step 2 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 2 [03/2024 - ]

  6. REMOVE REAR SEAT HEADREST ASSEMBLY (for RH Side) 

    Refer to PROCEDURE - Step 3

  7. REMOVE REAR SEAT CENTER HEADREST ASSEMBLY (for RH Side) 

    Refer to PROCEDURE - Step 4

  8. REMOVE REAR SEAT HEADREST ASSEMBLY (for LH Side) 

    Refer to PROCEDURE - Step 5

  9. REMOVE REAR SEATBACK ASSEMBLY RH (for RH Side) 
    Refer to PROCEDURE - Step 6
  10. REMOVE REAR SEATBACK ASSEMBLY LH (for LH Side) 
    Refer to PROCEDURE - Step 7
  11. REMOVE BENCH TYPE REAR SEAT CUSHION ASSEMBLY 
    Refer to PROCEDURE - Step 8
  12. REMOVE REAR SEAT CUSHION LOCK HOOK 

    Refer to PROCEDURE - Step 9

  13. REMOVE REAR DECK FLOOR BOX 

    Refer to PROCEDURE - Step 7 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 7 [03/2024 - ]

  14. REMOVE REAR FLOOR BOARD REAR RH 

    Refer to PROCEDURE - Step 8 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 8 [03/2024 - ]

  15. REMOVE JUNCTION BLOCK SERVICE COVER 

    Refer to PROCEDURE - Step 9 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 9 [03/2024 - ]

  16. REMOVE REAR FLOOR BOARD REAR LH 

    Refer to PROCEDURE - Step 10 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 10 [03/2024 - ]

  17. REMOVE FRONT DECK FLOOR BOX 

    Refer to PROCEDURE - Step 11 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 11 [03/2024 - ]

  18. REMOVE DECK BOARD SET SUPPORT 

    Refer to PROCEDURE - Step 12 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 12 [03/2024 - ]

  19. REMOVE REAR FLOOR FINISH PLATE 

    Refer to PROCEDURE - Step 34 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 34 [03/2024 - ]

  20. REMOVE REAR DOOR SCUFF PLATE 

    Refer to PROCEDURE - Step 21 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 21 [03/2024 - ]

  21. REMOVE NO. 3 BATTERY SERVICE COVER BOARD 

    Refer to PROCEDURE - Step 23 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 23 [03/2024 - ]

  22. DISCONNECT REAR DOOR OPENING TRIM WEATHERSTRIP 
    1. GTY1055903Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  23. REMOVE NO. 1 SIDE TRIM BASE COVER 

    Refer to PROCEDURE - Step 35 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 35 [03/2024 - ]

  24. REMOVE REAR SEAT SIDE GARNISH 

    Refer to PROCEDURE - Step 37 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 37 [03/2024 - ]

  25. REMOVE ROPE HOOK ASSEMBLY 
    Refer to PROCEDURE - Step 39 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 39 [03/2024 - ]
  26. REMOVE LUGGAGE HOLD BELT STRIKER ASSEMBLY 

    Refer to PROCEDURE - Step 40 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 40 [03/2024 - ]

  27. REMOVE NO. 1 LUGGAGE COMPARTMENT TRIM HOOK 
    Refer to PROCEDURE - Step 41 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 41 [03/2024 - ]
  28. REMOVE DECK TRIM SIDE PANEL ASSEMBLY LH 
    Refer to PROCEDURE - Step 42 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 42 [03/2024 - ]
  29. REMOVE DECK TRIM SIDE PANEL ASSEMBLY RH 
    Refer to PROCEDURE - Step 43 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 43 [03/2024 - ]
  30. DISCONNECT REAR SEAT OUTER BELT ASSEMBLY 
    1. GTY1055902Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
  31. REMOVE ROOF SIDE INNER GARNISH ASSEMBLY LH 

    Refer to PROCEDURE - Step 44 [11/2021 - 03/2024] , or refer to PROCEDURE - Step 44 [03/2024 - ]

  32. REMOVE REAR SEAT OUTER BELT ASSEMBLY 
    1. GTY1056622Courtesy of © TOYOTA, LICENSE AGREEMENT TMS1002
      1. Using a screwdriver, pull out the locking button as shown in the illustration to release the lock and disconnect the pretensioner connector.
      2. Remove the 3 bolts.
      3. Disengage the 2 guides.
scientia non olet · About LEMON Manuals