LEMON Manuals: Even more car manuals for everyone
Home >> Jeep >> 2017 >> Wrangler Sahara, Automatic Trans >> Repair and Diagnosis >> External Pages >> Different car >> Section 22 (Body - Interior & Exterior) >> Interior >> Headliner >> Removal

Section 22 (Body - Interior & Exterior): Interior: Headliner: Removal

WARNING: This page is about a different car, the 2017 Jeep Cherokee. However, it is still accessible from the selected car via links, so may be relevant.
GC0156019Courtesy of CHRYSLER GROUP, LLC
NOTE:

In the event the headliner is damaged or creased during removal, it will need to be replaced with a new headliner.

NOTE:

Please use clean gloves or ensure hands are clean before removing the headliner.

  1. Disconnect and isolate the negative battery cable. If equipped with an Intelligent Battery Sensor (IBS), disconnect the IBS connector first before disconnecting the negative battery cable.
  2. Support the headliner with a clean and suitable prop.
  3. Remove the right and left end caps from the instrument panel. Refer to CAP, INSTRUMENT PANEL END, REMOVAL .
  4. Disconnect the headliner wire harness (2) from the vehicle harness (1) on both sides.
    GC0159176Courtesy of CHRYSLER GROUP, LLC
  5. If equipped, remove the overhead console (3). Refer to CONSOLE, OVERHEAD, FRONT, REMOVAL .
  6. Remove both sided visors and visor supports. Refer to SUPPORT, VISOR, REMOVAL . Refer to VISOR, REMOVAL .
    GC0156313Courtesy of CHRYSLER GROUP, LLC
  7. Remove the front and rear grab handles. Refer to HANDLE, GRAB, REMOVAL .
  8. Remove the A-pillar trim panels, Refer to PANEL, A-PILLAR TRIM, REMOVAL .
    GC0159198Courtesy of CHRYSLER GROUP, LLC
  9. Detach the headliner wire harness (1) from the A-pillar.
  10. Disconnect the rear washer hose (2).
  11. Remove the B-pillar trim panels. Refer to PANEL, B-PILLAR TRIM, REMOVAL .
  12. Remove the upper quarter trim panels. Refer to PANEL, QUARTER TRIM, REMOVAL .
    GC0159184Courtesy of CHRYSLER GROUP, LLC
  13. Disconnect the electrical connector (2) and separate the rear support clips (1).
    GC0160042Courtesy of CHRYSLER GROUP, LLC
  14. Release the support clips (2) and separate the wire (1).
    GC0159177Courtesy of CHRYSLER GROUP, LLC
  15. Disconnect the rear washer hose (1) and electrical connectors (2).
    GC0159394Courtesy of CHRYSLER GROUP, LLC
  16. Release the front clips (1) and with the help of an assistant, remove the headliner (2) through the liftgate door opening.
    GC0159623Courtesy of CHRYSLER GROUP, LLC
  17. On sunroof models, release the front clips (4), release the dual lock fasteners (1) around the sunroof opening, and disconnect the electrical connector (2).
  18. Remove the headliner (3) through the liftgate door opening.
  19. If reinstalling the same headliner, place in a clean area free from dirt and debris.
scientia non olet · About LEMON Manuals