LEMON Manuals: Even more car manuals for everyone
Home >> Ford >> 2000 >> Contour SE, 2.5 L, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 134 (Instrument Panel - Analog - F150 Pickup (CNG)) >> Self-Diagnostic System >> Retrieving Diagnostic Trouble Codes >> Using Scan Tool

Using Scan Tool

WARNING: This page is about a different car, the 2002 Ford Pickup. However, it is still accessible from the selected car via links, so may be relevant.

For preliminary testing, see TROUBLE SHOOTING . If problem is not found, connect NGS tester to Data Link Connector (DLC). DLC is located below center of instrument panel, right of steering column. Perform data link diagnostic test. See DATA LINK DIAGNOSTIC TEST under SELF-DIAGNOSTIC SYSTEM in MODULE COMMUNICATIONS NETWORK - F150 PICKUP article. If NGS tester displays CKT914, CKT915 or CKT70 = ALL ECUS NO RESP/NOT EQUIP, repair module communications concern. See MODULE COMMUNICATIONS NETWORK - F150 PICKUP article. If NGS tester displays NO RESP/NOT EQUIP for Natural Gas Vehicle Module (NGVM), perform TEST J: NO COMMUNICATION WITH NATURAL GAS VEHICLE MODULE  under SYSTEM TESTS. If NGS tester displays NO RESP/NOT EQUIP for Hybrid Electronic Cluster (HEC), perform TEST A: NO COMMUNICATION WITH HYBRID ELECTRON under SYSTEM TESTS in ANALOG INSTRUMENT PANELS - F150 - GASOLINE.

If NGS tester displays SYSTEM PASSED, retrieve and record continuous DTCs. Erase continuous DTCs. Perform instrument cluster and NGVM self-test. If DTCs related to concern are retrieved, perform appropriate test. See NATURAL GAS VEHICLE MODULE DIAGNOSTIC TROUBLE CODE TEST INDEX  and/or HYBRID ELECTRONIC CLUSTER DIAGNOSTIC TROUBLE CODE TEST INDEX  tables. If DTCs not related to concern are retrieved, perform diagnostics on HEC. See USING HYBRID ELECTRONIC CLUSTER . If no DTCs are retrieved, repair by symptom. See SYMPTOM INDEX  table under SYSTEM TESTS.

NATURAL GAS VEHICLE MODULE DIAGNOSTIC TROUBLE CODE TEST INDEX

DTC Description Perform Test
B1219 Fuel Tank Pressure Sensor Circuit Failure A 
B1220 Fuel Tank Pressure Sensor Circuit Short To Power B 
B1222 Fuel Tank Temperature Sensor Circuit Failure C 
B1223 Fuel Tank Temperature Sensor Circuit Open D 
B1224 Fuel Tank Temperature Sensor Circuit Short To Power E 
B1225 Fuel Tank Temperature Sensor Circuit Short To Ground F 
B1317 Battery Voltage High G 
B1318 Battery Voltage Low H 
B1342 ECU Defective I 
P1197 Select/Reset Switch Circuit Failure (1)
(1) Using NGS tester, retrieve and document all continuous codes. Perform hybrid electronic cluster self-test. If DTC sets again, replace HEC. See INSTRUMENT CLUSTER  under REMOVAL & INSTALLATION.
HYBRID ELECTRONIC CLUSTER DIAGNOSTIC TROUBLE CODE TEST INDEX

DTC (1) Description Perform Test
B1202 Fuel Sender Open L 
B1204 Fuel Sender Short To Ground L 
B1342 ECU Defective (2)
(1) Codes listed in this table are only for testing covered in this article. For complete diagnostic trouble code listing, see MODULE COMMUNICATIONS NETWORK - F150 PICKUP article.
(2) Using NGS tester, retrieve and document all continuous codes. Perform hybrid electronic cluster self-test. If DTC B1342 is retrieved again, replace HEC. See INSTRUMENT CLUSTER  under REMOVAL & INSTALLATION.
scientia non olet · About LEMON Manuals