LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2017 >> Malibu LS >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 5 (Engine Controls And Fuel - 1.8L (LKN) - Repair Instructions) >> Repair Instructions >> Fuel Feed Pipe Replacement - Underbody >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
  1. Relieve the fuel system pressure. Refer to Fuel Pressure Relief 
    WARNING: Refer to Gasoline/Gasoline Vapors Warning .
    WARNING: Refer to Safety Glasses Warning .
  2. Fuel Feed Front Pipe @ Fuel Feed Pipe - Underbody - Disconnect Fuel Feed Front Pipe Replacement 
  3. Underbody Rear Air Deflector-Right Side - Remove Underbody Rear Air Deflector Replacement - Right Side (XFE)
  4. Front Cradle Brace - Right Side - Remove Front Cradle Brace Replacement
  5. Brake and Fuel Pipe Shield (1) - Remove
    Fig 1: Brake and Fuel Pipe Shield
    GM4244586Courtesy of GENERAL MOTORS COMPANY
  6. Fuel Feed Pipe (1) @ Retainer (2) - Remove [5x]
    Fig 2: Fuel Feed Pipe
    GM4244594Courtesy of GENERAL MOTORS COMPANY
  7. Fuel Feed Pipe (1) @ Fuel Feed Pipe (2) - Disconnect Plastic Collar Quick Connect Fitting Service
    Fig 3: Fuel Feed Pipe Retainers
    GM4244450Courtesy of GENERAL MOTORS COMPANY
  8. Fuel Feed Pipe (1) @ Retainer (3) - Remove [5x]
scientia non olet · About LEMON Manuals