LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2015 >> Cruze LT, Automatic Trans >> Repair and Diagnosis >> External Pages >> Different car >> Section 52 (Engine Controls And Fuel - 1.4L (LUV) - Repair Instructions) >> Repair Instructions >> Fuel Tank Replacement (AWD) >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2015 Chevrolet Trax and 2015 Buick Encore. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the fuel sender assembly. Refer to Fuel Sender Assembly Replacement (AWD) .
  2. Transfer the fuel tank fuel pump module. Refer to Fuel Tank Fuel Pump Module Replacement (FWD).
  3. Transfer the evaporative emission canister. Refer to Evaporative Emission Canister Replacement (AWD) .
  4. Install the fuel tank to the hydraulic lift.
    5. Fig 1: Fuel Tank Straps And Fasteners
    GM2783760Courtesy of GENERAL MOTORS COMPANY
  5. With the aid of an assistant, position the fuel tank to the vehicle.
    6. CAUTION:

    Refer to Fastener Caution .

  6. Install both fuel tank straps to the fuel tank (2) and tighten the fasteners to 22 N.m (16 lb ft).
  7. Remove the hydraulic lift from the fuel tank.
  8. Connect the EVAP system hoses. Refer to Evaporative Emission System Hose/Pipe Replacement (2H0) Evaporative Emission System Hose/Pipe Replacement (Fuel Pump Module to Vent Pipe FWD) Evaporative Emission System Hose/Pipe Replacement (Fuel Pump Module to Canister FWD) Evaporative Emission System Hose/Pipe Replacement (Canister to Pipe FWD).
  9. Connect the fuel feed pipe. Refer to Fuel Feed Pipe Replacement (2H0) Fuel Feed Pipe Replacement (At Tank FWD).
  10. Connect the fuel tank filler pipe. Refer to Fuel Tank Filler Pipe Replacement.
    11. Fig 2: Fuel Tank Fuel Pump Module Wiring Harness
    GM2781400Courtesy of GENERAL MOTORS COMPANY
  11. Connect the fuel tank fuel pump module wiring harness (1) and clip the fuel tank module wiring harness to the chassis.
  12. Install the propeller shaft. Refer to Two-Piece Propeller Shaft Replacement .
  13. Install the exhaust. Refer to Exhaust Muffler Replacement (2H0)Exhaust Muffler Replacement (LUV) .
  14. Install the right rear wheelhouse panel liner. Refer to Rear Wheelhouse Liner Replacement .
  15. Lower the vehicle.
scientia non olet · About LEMON Manuals