LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2002 >> Blazer 4D Utility, 4WD, Part Time >> Repair and Diagnosis >> External Pages >> Different car >> Section 1982 (Hybrid Engine Electrical System 2.4L (Hp7)) >> Repair Instructions >> Battery Replacement (HP7) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2009 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
WARNING: Do not tip the battery over a 45 degree angle or acid could spill causing serious personal injury.
  1. Remove the generator battery control module cover. Refer to Generator Control Module Cover Replacement .
  2. Disconnect the negative battery cable. Refer to Battery Negative Cable Disconnection and Connection (HP7) .
    3. Fig 1: ECM Bracket Bolts And Nuts
    GM2030262Courtesy of GENERAL MOTORS CORP.
  3. Remove the ECM bracket bolts (2), nuts (1) and ECM bracket.
  4. Set the ECM assembly aside.
    5. Fig 2: Positive Battery Cable Terminal Nut
    GM1999419Courtesy of GENERAL MOTORS CORP.
  5. Loosen the positive battery cable terminal nut (1) and secure the battery positive cable (2) out of the way.
    6. Fig 3: Battery Hold Down Nuts
    GM1999432Courtesy of GENERAL MOTORS CORP.
  6. Remove the battery hold down nuts (1) and the battery hold down retainer bracket (2).
  7. Remove the battery from the vehicle.
scientia non olet · About LEMON Manuals