Raise the front axle support and fasten it
Raise front axle support
Do not damage the steering gear
NOTE:
RISK OF DAMAGE
Failure to comply with the specification.
Component damage.
Failure to comply with the specification.
Component damage.
- All specifications for installation and removal must be observed.
- When lifting the front subframe, ensure sufficient distance between the steering gear (1) and the output shaft (2).NOTE: Perform the steps on the right and left side.
- Position the front axle support (1) to the right and left on the adapter for the front axle support (2).
- Carefully raise the front axle support with the universal jack 0 490 133 (00 2 030)
and position on the body.
Fasten front axle support
Securing the front axle support adapter on the front axle support on the right and left
NOTE: Perform the steps on the right and left side. - Position the adapter (1) for the front subframe (2) on the front subframe (2).
- Tighten down screws (3).TIGHTENING TORQUES SPECIFICATION
Adapter, front axle support to front axle support M8x80 Tightening torque 19 Nm Attaching left and right crash levers
NOTE: The following step(s) must be performed if the listed component(s) is/are installed. - Replace nut (1).
Parts: Nut
- Insert screw (2).
- Tighten nut (1).TIGHTENING TORQUES SPECIFICATION
Crash lever on front subframe M12 Replace nut. tightening torque 65 Nm - Replace screws (1) to (3).
Parts: screw
- Tighten down screws (1).TIGHTENING TORQUES SPECIFICATION
Front axle carrier to body, front M12x115 Replace screws. Joining torque 100 Nm Angle of rotation 90° - Tighten down screws (2).TIGHTENING TORQUES SPECIFICATION
Front axle support to center of body M12x90 Replace screws. Joining torque 100 Nm Angle of rotation 90° - Tighten down screws (3).TIGHTENING TORQUES SPECIFICATION
Front axle carrier to body, rear M14 Replace screws. Joining torque 100 Nm Angle of rotation 90° - If necessary, remove the special tool (tensioning strap) 0 496 080 (33 5 206) .
- Lower the universal jack 0 490 133 (00 2 030)
and place to one side.
Follow-up work
- Refer to SECURING THE ANTI-ROLL BAR LINK ON THE LEFT AND RIGHT ON THE ANTI-ROLL BAR .
- Refer to FASTENING ELECTRIC COOLANT PUMP AND COOLANT HOSES TO THE FRONT AXLE SUPPORT
- Refer to IF INSTALLED: CONNECT THE VACUUM LINE OF THE ENGINE MOUNTS .
- Refer to ATTACHING THE LINE CONNECTION OF THE RIDE HEIGHT SENSOR
- Refer to SECURING THE EPS WIRING HARNESS TO THE ELECTROMECHANICAL STEERING GEAR .
- Refer to INSTALLING STEERING SHAFT AT BOTTOM ON STEERING GEAR
- Refer to INSTALLING THE COVER PANELS ON THE FRONT AXLE ON THE RIGHT AND LEFT .
- Refer to INSTALLING THE FRONT UNDERBODY PROTECTION .
- Refer to INSTALLING THE FRONT LEFT AND RIGHT WHEELS .
- Refer to RECONNECTING ALL BATTERY GROUND LEADS .