Wheel Alignment, Checking/Adjusting: General

WARNING: This page is about a different car, the 2004 Volvo S40, 2003 Volvo S40, 2002 Volvo S40, 2001 Volvo S40, and 2000 Volvo S40. However, it is still accessible from the selected car via links, so may be relevant.

NOTE: The following applies when checking and adjusting wheel alignment:

All measurements must be made using alignment equipment for four-wheel drive vehicles
All readings must be taken on an empty car (the fuel level in the fuel tank does not matter)
Check all the tire pressures before beginning measurement.

NOTE: Model year 2001-, note the car chassis type. See Identifying the Chassis Type .

CAUTION: Before taking readings, check that the steering wheel position is straight. When adjusting the front toe-in, correct any misalignment at the same time. For major steering wheel misalignment, adjust the position of the steering wheel as follows:

For model year -2000, see Steering Wheel Module, Steering Wheel And Contact Reel, Replacement
For model year 2001-2002, see Steering Wheel Module And Steering Wheel
For model year 2003-, see Steering Wheel Three Spoke, Replace .