The following components must always be inspected and replaced if damaged:
WARNING: This page is about a different car, the 2004 Volvo S40, 2003 Volvo S40, 2002 Volvo S40, 2001 Volvo S40, and 2000 Volvo S40. However, it is still accessible from the selected car via links, so may be relevant.
- The front windshield and the bonding for the front windshield.
NOTE:
PUR adhesive must be used when replacing the front windshield. Carefully remove all broken glass. Also check the ventilation ducts.
Only applies to USA:
NOTE:
The brackets must be replaced if the dashboard or the lower panel on the driver's side is damaged. Tighten the new
brackets. Tighten to 25 Nm
.
- The entire rear seat assembly with accompanying posts and anchorages if these have been affected during the collision.