Check the Fuel Lines

WARNING: This page is about a different car, the 2002 Volvo C70, 2001 Volvo C70, 2000 Volvo C70, 1999 Volvo C70, and 1998 Volvo C70. However, it is still accessible from the selected car via links, so may be relevant.

Fig 1: Connecting Connector

Courtesy of VOLVO CARS OF NORTH AMERICA.

Connect the control module connectors
Remove the fuel line at the heater
Hold a container at the end of the fuel line.
- Start the heater. Wait 1 minute until the fuel pump (FP) has started to pump.
  NOTE: The engine coolant temperature (ECT) must be lower than 55°C.

Fuel must flow out of the fuel line.

OK
Refer to Verify
NOT OK
Refer to Repairs, Wiring And Terminals

Fig 1: Connecting Connector

Courtesy of VOLVO CARS OF NORTH AMERICA.

Connect the control module connectors
Remove the fuel line at the heater
Hold a container at the end of the fuel line.
- Start the heater. Wait 1 minute until the fuel pump (FP) has started to pump.
  NOTE: The engine coolant temperature (ECT) must be lower than 55°C.

Fuel must flow out of the fuel line.

OK
FAULT NOT FOUND: Troubleshooting has been completed.
NOT OK
Refer to Repairs, Wiring And Terminals