Preparations for installing the sub-frame
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.
CAUTION:
Make sure that no hoses, wiring, or other components get stuck or are trapped when lifting the engine/transmission unit.
CAUTION:
Do not damage the brake pipe running to the right front wheel.
Raise the engine / transmission unit. Use a lifting table.
Continue raising the unit until it is only approximately 50 mm from its correct position.
Move the fuel line into place.
Secure the two screws on the right-hand side of the anti-roll bar.
CAUTION:
Guide the lower steering wheel shaft into the hole in the firewall.