Components Inside Front Passenger Compartment Component Location (Manual A/C System)
WARNING: This page is about a different car, the 2016 Volkswagen Beetle, 2015 Volkswagen Beetle, 2014 Volkswagen Beetle, 2013 Volkswagen Beetle, and 2012 Volkswagen Beetle. However, it is still accessible from the selected car via links, so may be relevant.
- Instrument Panel
- Instrument panel with defrost air vent
- Air guide channels installed under the instrument panel
- Air guide channel assembly overview. Refer to VENTS
- For removing and installing the instrument panel, refer to INSTRUMENT PANEL .
- Center Air Vent
- Air ducts and air distribution in passenger compartment assembly overview. Refer to AIR DUCTS AND AIR DISTRIBUTION IN PASSENGER COMPARTMENT OVERVIEW .
- Removing and Installing. Refer to CENTER AIR VENT .
- Right Side Window Vent
- The air distribution is activated using the defroster intermediate piece -item 10-.
- Removing and Installing. Refer to SIDE WINDOW VENTS .
- Right Side Vent
- The air distribution is activated using the intermediate piece for the air vent -item 11-.
- Removing and Installing. Refer to SIDE VENTS .
- Front A/C Display Control Head -E87- with A/C Control Module -J301-
- Two-piece version
- Rear heat controls, refer to DISPLAY CONTROL HEAD, REAR SECTION
- Function. Refer to DISPLAY CONTROL HEAD (ELECTRIC MANUAL A/C SYSTEM) .
- For the multi-pin connector assignment, refer to PIN ASSIGNMENT ON BACK OF DISPLAY CONTROL HEAD (ELECTRIC MANUAL A/C SYSTEM) .
- Removing and Installing. Refer to DISPLAY CONTROL HEAD .
- With Fresh Air Blower Switch -E9-
- With Fresh Air/Recirculation Door Switch -E159-
- Also with Immediate Heating Button -E537- in vehicles with auxiliary heater
- Depending on the vehicle equipment level, with Seat Heating/Ventilation Adjuster -E399-
- Recirculation Door Motor -V113-
- With the Recirculation Door Motor Position Sensor -G143-
- Checking: Vehicle Diagnostic Tester
- Removing and Installing. Refer to Air Recirculation Door Motor -V113- WITH Recirculation Door Motor Position Sensor -G143- .
- Fresh Air Blower -V2-
- Checking: Vehicle Diagnostic Tester
- Removing and Installing. Refer to Fresh Air Blower -V2- .
- Front Passenger Side Footwell Vent
- Removing and Installing. Refer to FRONT PASSENGER SIDE FOOTWELL VENT .
- Dust and Pollen Filter
- with activated charcoal insert
- Dust and pollen filter general information. Refer to DUST AND POLLEN FILTER .
- Removing and Installing. Refer to DUST AND POLLEN FILTER .
- Front Passenger Side Footwell Trim Panel
- Condensation Water Drain
- Checking. Refer to CONDENSATION WATER DRAIN .
- Removing and Installing. Refer to CONDENSATION WATER DRAIN .
- Fresh Air Blower Series Resistor with Fuse -N24-
- Removing and Installing. Refer to Fresh Air Blower Series Resistor with Fuse -N24- .
- Evaporator Temperature Sensor -G308-
- Removing and Installing. Refer to Evaporator Temperature Sensor -G308- .
- Right Rear Vent Air Guide Channel
- Removing and Installing. Refer to REAR VENT AIR GUIDE CHANNEL .
- Left Rear Vent Air Guide Channel
- Removing and Installing. Refer to REAR VENT AIR GUIDE CHANNEL .
- Sealing Caps
- Only for vehicles without air ducts/air vents installed in the rear center console
- Removing and Installing. Refer to CAPS ON HEATER AND A/C UNIT .
- Auxiliary Heater Heating Element -Z35-
- Only installed on vehicles with Diesel engine without auxiliary water heater
- Removing and installing. Refer to Auxiliary Heater Heating Element -Z35- .
- Switch-on criteria. Refer to Installing .
- Switch-off criteria. Refer to Installing .
- Heater Core
- Removing and installing. Refer to HEATER CORE .
- After replacing heater core, replace all the coolant. Refer to COOLANT, DRAINING AND FILLING (CJAA, CVCA) , COOLANT, DRAINING AND FILLING (CPLA, CPPA, CPKA, CPRA) or COOLANT, DRAINING AND FILLING (CBTA, CBUA) .
- Driver Side Footwell Vent
- Removing and Installing. Refer to DRIVER SIDE FOOTWELL VENT .
- Heater and A/C Unit
- Heater and A/C unit, removing and installing. Refer to HEATER AND A/C UNIT .
- Heater and A/C unit attachments assembly overview. Refer to HEATING AND A/C UNIT COMPONENTS .
- Heater and A/C unit, disassembling and assembling. Refer to HEATER AND A/C UNIT OVERVIEW (MANUAL A/C SYSTEM) .
- Evaporator housing assembly overview. Refer to EVAPORATOR HOUSING OVERVIEW .
- Left Side Vent
- The air distribution is activated using the intermediate piece for the air vent -item 11-.
- Removing and Installing. Refer to SIDE VENTS .
- Left Side Window Vent
- The air distribution is activated using the defroster intermediate piece -item 10-.
- Removing and Installing. Refer to SIDE WINDOW VENTS .